|
NEMO�etc.
<br /> 11 For mechanically attached components over existing decks,fasteners shall be tested in the existing deck for withdrawal resistance.A qualified design professional shall review the data for comparison to the
<br /> minimum requirements for the system.Testing and analysis shall be in accordance with ANSI/SPRI FX-1 or Testing Application Standard TAS 105.
<br /> 12 For bonded insulation or membrane over existing substrates in a re-roof(tear off)orrecover installation,the existing deck or existing roof surface shag be examined for compatibility with the adhesive to be r
<br /> installed.If any surface conditions exist that bring system performance into question,field uplift testing In accordance shall be conducted on mock-ups of the proposed new roofassembly.For bonded insulation
<br /> or membrane over existing substrates Ina recover Installation,the existing roof system shall be capable of resisting project design pressures on Its own merit to the satisfaction of the Authority Having
<br /> Jurisdiction,as documented through field uplift testing.Field uplift testing shall be in accordance with ASTM E907,FM Loss Prevention Data Sheet 1-52 or Testing Application Standard TAS 124.
<br /> 13 Refer to FBC 2511 for requirements and limitations regarding recover installations.For Structural Concrete Deck or Recover Applications using System Type C-1,C-2,D3 or D-2,the Insulation is optional.
<br /> Alternatively,an FBC Approved Insulation board or overboard maybe used as a separation layer.Board products shall be preliminarily attached prior to roof cover Installation(Note 5 herein).The separator
<br /> component shall be documented as meeting FBC 1505 and,for foam plastic,FBC Chapter 25,when installed with the roof cover in Recover applications.
<br /> 14 Lightweight insulating concrete(LWIC)shall be cast in accordance with FBC Section 1917 to the satisfaction of the Authority Having Jurisdiction.For systems where specific LWIC is referenced,refer to mrwnt
<br /> LWIC Product Approval for specific deck construction and limitations.Unless otherwise noted,for systems where specific LWIC is not referenced,the minimum design mix shall be 300 psi.Inallcases,the
<br /> minimum top-mat thickness is 2-Inches.For LWIC over structural concrete,reference is made to FBC Section 1917.4.1,Paint 1.For'pre-existent'LWICreferences,listings were establishedthrough testing over
<br /> lightweight concrete cast using only foaming agent(ASTM C895),water and Portland cement(ASTM C150),with no proprietary additives,in accordance with procedures adopted by Miami-Dade BCCO(FBC
<br /> CER3592).Use of these listings in new construction or re-roof(tear-off)applications is at the discretion of the Designer or Record and Authority Having Jurisdiction.
<br /> 15 For single-ply membranes in System Type D-1 steel deck applications,the mofinembmne shall be run with its length perpendicularto the steel deckflutes.For bonded membrane applications,unlessotherwlse
<br /> noted,refer to the following.
<br /> MCMSRA a/AOHLSN[CDNnnUtrots` .
<br /> REFERENCE, ,,LAYER MATERIAL APPLICATION
<br /> BP-AA Base PM GAFGLAS 07S Base Sheet,Tri-Ply 075 Base Sheet,GAFGLAS A80 Ultlma Base Sheet Hot asphalt at 251bs/square.
<br /> (Base/Ply sheets,Asphalt-Appled) Ply: One or more plies GAFGLAS Ply 4,Tri-Ply Ply 4 Ply Sheet,GAFGLAS FlexPly6
<br /> BP-CA Base Ply: GAFGLAS 075 Base Sheet,Tri-0ty 975 Base Sheet MaU[x102SBSMembrsne
<br /> (Base/Ply sheets,Cold-Applied) Adhesive at 15 gal/sq.
<br /> Base Ply or PIy: One or two plies Ruberoid 20 Smooth,Ruberoid Mop Smooth,Ruberoid Mop Smooth 15,Ruberold Mop Plus Smooth
<br /> SBS-AA Ruberoid 30 Granule,Ruberold 30 Granule FR,Ruberoid EnergyCap 30 Granule FR,Ruberoid Mop Smooth,Ruberoid
<br /> (SBS,Asphalt-Applied) Cap Ply, Mop Smooth 1.5,Ruheroid Mop Plus Smooth,Ruberold Mop Granule Fit,Ruberoid Mop Granule,Tri-PIy SBS Granule Hot asphalt at 25 lbs/square.
<br /> Cap Sheet,Inter Flex PRF,Ruberoid Mop Plus Granule FR,Ruberoid Mop Plus Granule,Ruberold EnergyCap Mop Plus
<br /> Granule FR
<br /> SBS-CA Base Ply or Ply. Ruberoid 20 Smooth
<br /> (SBS,Cold-Applied) Cap PIT. Ruberoid 30 Granule FR,Ruberoid EnergyCap 30 Granule FR,Ruberoid Mop Granule FR,Ruberold Mop Plus Granule Matrix 102 SBS Adhesive at IS Membrane
<br /> FR,Ruberoid EnergyCap Mop Plus Granule FR
<br /> SBS.CA1 Base Ply: Ruberoid 20 Smooth or Ruberoid Mop Smooth 1.5 Matrix 101 Premium SRS
<br /> (SBS,Cold-Applied) Cap Ply. Ruberoid 30 Granule FR,Ruberoid EnergyCap 30 Granule FR,Ruberoid Mop Plus Granule FR,Ruberoid EnergyCap Mop Membrane Adhesive atl5—
<br /> Plus Granule FR 2.0 gal/square
<br /> SBS-TA Base Ply or Ply. One or two plies Ruberoid HW 25 Smooth,Ruberoid HW Smooth
<br /> (SBS,Tomh.Applied) Cap Ply. Ruberaid HW Granule,Ruberoid HW Granule FR,Rubemid HW Plus Granule,Ruberoid HW Plus Granule FR,Ruberoid
<br /> EnergyCap HW Plus Granule FR
<br /> APP-TA Base Ply or Ply. One or two plies Ruberoid Torch Smooth,Tri-Ply APP Smooth Membrane Torch applied
<br /> (APP,Torch-Applied) Up Ply Ruberold Torch GranUie,Tri-PIy APP Granule Membrane,Ruberoid Torch Plus Granule FR,Ruberoid EnergyCap Torch
<br /> Granule Fit,Ruberoid EnergyCap Torch Plus Granule FR
<br /> SBS-SA(self-adhering) Base Ply or PM Liberty SBS Self-Adhering Base/Ply Sheet Self-adheredCap Ply Liberty SBS Self-Adhering Cap Sheet
<br /> NEMO ETC,LLC Evaluation Report 01506.11.041129 for F1.5680-1129
<br /> Certificate of Authorization p32455 7-EDITION 12020)FBC NON•HVH2 EVALUATION Revision 29:10/11/2020
<br /> 02019 NEMO ETC,LLC GAF Modified Bitumen Roof Systems;(800)76G3411 Appendix 1,Page 3 of 91
<br /> ONEMOjetc.
<br /> 16 Vapor barrier options for use over structural concrete deck followed by bonded Insulation carry the following MOP limitations.The lesser of the MDP listings below vs.those In Table 3A applies.
<br /> VAPOR Blumvrpr7roNs;SixUQuaxl[oMUErEDLa:Fouvwm erAONmvE-AwuTo lRsutA7roerPaTxetE3A:
<br /> OPTION - 'PRIMER .. - -. VAPOR BARRIER .. „- INSULATION ADHESIVE_ MOP
<br /> .TYPE .APPLICATION -(PSF)
<br /> C-VB-1. Matrix 307 Premium Asphalt Primer orASTM D4lprimer One ortwo plies,GAFGLAS 075 Base Sheet,Tri-Ply 075 Base Hat asphalt applied Hot asphalt -360.0
<br /> Sheet,GAFGLAS Ply 4,Tri-Ply Ply 4 Ply Sheet or GAFGLAS FlexPly 6
<br /> C-VB-2. Matrix 307 Premium Asphalt Primer or ASTM D41 primer Rubemid Torch Granule Torch-applied GAF 2-Part,12-Inch o.c. -169.0
<br /> C-VB3. Matrix 307 Premium Asphalt Primer or ASTM D41 primer Ruberoid HW 25 Smooth or Ruberold HW Smooth Torchapplied GAF 2-Part,12-inch o.c. -180.0
<br /> C-VB4. GAF SA Primer GAF SAVapor Retarder Self-adhering GAF 2-Part,12-inch o.c. -2025
<br /> C-VB-S. Matrix 307 Premium Asphalt Primer or ASTM D41 primer Liberty SBS Self-Adhering Cap Sheet Self-adhering GAP 2-Part,12-inch o.c. -250.0
<br /> C-VB-6. Matrix 307 Premium Asphalt Primer or ASTM D41 primer One or two plies,GAFGLAS 075 Base Sheet,Tri-Ply 475 Base Hot asphalt applied GAF 2-Part,12-inch o.c. -2625
<br /> Sheet,GAFGLAS Ply 4,Tri-Ply Ply 4 Ply Sheet or GAFGLAS FlexPly fi
<br /> C-VB-7. Matrix 307 Premium Asphalt Primer or ASTM D41 primer Ruberoid 30 Hot asphalt applied GAF 2-Part,12-inch o.c. -270.0
<br /> C-VB-B. Matrix 307 Premium Asphalt Primer or ASTM D41 primer, Rubemid HW 25 Smooth or Ruberoid HW Smooth Torch-applied LRF-M,12-inch o.c. -180.0
<br /> C-VB_9. GAFSAPrimer GAF SA Vapor Retarder Self-adhering LRF-M,12-inch o.c. -2025
<br /> C-V&10. Matra 307 Premium Asphalt Primer or ASTM D41 pdmer One or two plies,GAFGLAS 075 Base Sheet,Tri-Ply 475 Base Hat asphalt applied LRf-M,12-inch o.c. -495.0
<br /> Sheet,GAFGLAS Ply 4,Td-Ply Ply 4 PIy Sheet or GAFGLAS FlexPly 6
<br /> C-VB-11. Matrix 307 Premium Asphalt Primer or ASTM D41 primer Ruberoid Torch Smooth Torch-applied 0lyBond 500,12-inch o.c. -165.0
<br /> C-VB-12. Matra 307 Premium Asphalt Primer or ASTM D41 primer Rubemid HW 25 Smooth Torch-applied OlyBond 500,12-inch o.c. -180.0
<br /> C-VB-13. Matrix 307 Premium Asphalt Primer or ASTM D41 primer Liberty SBS Self-Adhering Cap Sheet Self-adhering OlyBond 5D0,12-inch o.c. -1875
<br /> C-VB-14. Matra 307 Premium Asphalt Primer or ASTM D41 primer Ruberoid 20 Smooth Matra 1025BS Membrane Adhesive at 1.5 gaVsquare 0lyBand 500,12-Inch o.c. -2025
<br /> CWB-35. GAF SA Primer GAF SAVapor Retarder Self-adhering OlyBond 500,12-Inch o.c. -2025
<br /> C.VB-16. Matrix 307 Premium Asphalt Primer or ASTM D41 primer Ruberoid Torch Granule Torth-applied OlyBond 500,12-inch o.c. -225.0
<br /> C-VB-17. Matrix 307 Premium Asphalt Primer or ASTM D41 primer Ruberold HW Smooth Torch-applied OlyBond 500,12-inch o.c. -2325
<br /> C-VB-18. Matra307 Premium Asphalt Primer or ASTM D41 primer One or two plies,GAFGLAS A75 Base Sheet,Tri-Ply 875 Base Hot asphalt applied Olyeond 500,12-inch a.c. -3525
<br /> Sheet,GAFGLAS Ply 4,Tri-PIy Ply 4 Ply Sheet or GAFGLAS FlexPly 6
<br /> 16A Vapor barrier options for over structural concrete deck followed by cellular lightweight insulating concrete carry the following Maximum Design Pressure(MDP)limitations.The lesser of the MDP listings below
<br /> vs.those in Tables 4A through 4D applies.
<br /> VAPOABANUHIOPProNP;STIUC1UMCORCIETEDra FOLLOww RYCELLUTARIIGRIWHGHf L"utAy IGCGNCRETEPERTANES4A"MDUGH4D:
<br /> •PR OPTION - IMER - - - VAPOR BARRIER - LIGHTWEIGHT MDP TYPE - ATTACH CONCRETE (PSF)
<br /> Matra 307 Premium Asphalt Base Ply(Optional):One or two plies Rubemid HW 2S Smooth,Ruberold HW Smooth Torch- Min.200 psi
<br /> LWC-VB-L Primer or ASTM D41 primer Cap Ply:Ruberoid HW Granule,Ruberoid HW Granule FR,Ruberold HW Plus Granule,Ruberoid HW Plus Granule FR applied Mearicrete(FL13492) $2-5
<br /> Matrix 307 Premium Asphalt Base Ply(Optional):One or two plies Ruberoid HW 25 Smooth,Ruberoid HW Smooth Torch- Min.300 psi Celcore
<br /> LWC-VB-L Primer orASTM D4l primer Cap Ply:Ruheroid HW Granule,Ruberoid HW Granule FR,Ruberoid HW Plus Granule,Ruberoid HW Plus Granule FR applied (FL203Cellularfnnuete -135.0
<br /> (FI2037)
<br /> LWC VB-3 Matra 307 Premium Asphalt Base Ply(Optional):One or two plies Ruberoid HW 25 Smooth,Ruberoid HW Smooth Torch- Min.300 psi Elastizell -3025
<br /> Primer or ASTM D41 primer 1 Cap PIy.Ruberoid HW Granule,Ruberoid HW Granule FR,Ruberoid HW Plus Granule,Ruberoid HW Plus Granule FR applied I(FL4994)
<br /> NEMO ETC,LLC Evaluation Report 01506.11.04-R29 for FLS6g0-RZ9
<br /> Certificate of Authorization A32455 7-EDITION(20201 FBC NON.HVHZ EVALUATION Revision 29:10/11/2020
<br /> 02019 NEW ETC,LLC GAF ModI led Bitumen Roof Systems,(SDD)7663411 Appendix 1,Page 4 of 91
<br />
|