|
•ICI '' I�_I
<br />MIA ?4LAW-DAD>tCOUN,TY
<br />PRODUCT CONTROL SECTION
<br />DEPARTM W OF REGULATORY AND ECONOMIC RESOURCES (RER) l l W5 SW 26 Sure4,Room 208
<br />BOARD AND CODE ADNMIST"TTON DIVISION Miami, Florida 33175-2474
<br />T (786) 315-2590 F (786) 3 0-599
<br />NOTICE OF ACCEPTANCE (NOA) w.vw.miamidtdejWWeeonomv
<br />Cast: Crete USA, LLC
<br />63U County Road 379
<br />Seffur> Florida 33584
<br />SCOPE..
<br />This NOA Is being issued under the applicable rules and regulations governing the use of construction materials.
<br />The documentation submitted has been reviewed and accepted by Miami -Dade County RER- Product Control
<br />Section to be used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction
<br />(AIM,
<br />This NOA shall not be valid alter the expiration date stated below. The Miami -Dade County Product Control
<br />Section (In Miami .Dade County) and/or the AW (in areas other than Miami Dade County) reserve the right to have
<br />this product or material tested for quality assurance purposes. If this product or material fails to perform in the
<br />accepted manner, the manufacturer will incur the expense of such testing and the AHJ may immediately revoke,
<br />modify, or suspend the use of such product or material within their jurisdiction. RER reserves the fight to revoke
<br />this acceptance, if it is determined by Miami -Dade County Product Control Section that this product or material
<br />fails to meet the requirements of the applicable building code.
<br />This product is approved as described herein and :has been designed to comply with the High Velocity Hurricane
<br />Zone of the Florida Building Code.
<br />DESCRIPTION: ( Cost -Crete) 4", 6" & 12" High Strength Pttcast and Prestressed Concrete Lintels
<br />APPROVAL DOCUMENT: Drawing No. FD4612, tided "Precast and Prestressed LinteI Details", slue 1 of 1,
<br />prepared by Craig Parrino, P.E., dated March 24, 2003 and Drawing No. LT4612, titled "Cast -Crete 4", V & 12"
<br />Lintel Safe Load Tables", sheets 1 through 3 of 3, prepared by Craig Parrino, P.E., dated March 24, 2003, last
<br />revision dated June 12, 2014, all signed and sealed by Craig Parrino, P.E., on January 22, 2019, all bearing the
<br />Miami -Dade County Product Control Revision stamp with the Notice of Acceptance number and the expiration
<br />date by the Miami -Dade County Product Control Section.
<br />MISSILE IMPACT RATING: Large and Shall Missile Impact Resistant
<br />LABELING: Each lintel shall bear a permanent label with the manufacturer's name or logo and the Miami -Dade
<br />County logo.
<br />RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no
<br />change in the applicable building code negatively affecting the performance of this product.
<br />TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
<br />materials, use, and/or manufacture of the product or process. Misuse of this NOA as an endorsement of any
<br />product, for sales, advertising or any other purposes shall automatically terminate this NOA. Failure to comply with
<br />any section of this NOA shall be cause for termination and removal of NOA.
<br />ADVERTISEMENT: The NOA number preceded by the words Marini -Dade County, Florida,, and followed by
<br />the expiration date may be displayed in advertising literature. If any portion of the NOA is displayed, then it shall
<br />be done in its entirety.
<br />INSPECTION: A copy ofthis entire NOA shall be provided to the user by the manufacturer or its distributors and
<br />shall be available far inspection at the job site at the request of the Building Official.
<br />This NOA revises NOA # 19-OU&I4 and consists of this page 1, evidence submitted pages E-1, E-2, E-3, E4 and
<br />E-5 as well as approval document mentioned above.
<br />The submitted documentation was reviewed by Helmy A. Makar, P.E., M.S.
<br />A &"i. NOA No. 204WO.15
<br />Expiration Date: "A 14023
<br />Approval Date: OWW2020
<br />Page 1
<br />Cast-Criete US - LLC
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
<br />7. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 18-0424.04
<br />A. DRAWINGS
<br />1. None.
<br />B. TESTS
<br />1. None.
<br />C. CALCULATIONS
<br />1. None.
<br />D. QUALITY ASSURANCE
<br />L By Afiami-Dade Cormty Department of Regulatory and Economic Resources MER).
<br />E, MATERIAL CERTIFICATIONS
<br />1. None.
<br />F. OTHER
<br />1. Compliance Letter with the Florida Building Code, 2017 Edition, issued by Cast -
<br />Crete USA, Inc., dated 08108117, signed & sealed by Craig Parrino, P. E
<br />8. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 19-0130.14
<br />A. DRAWINGS
<br />1. Drawing No. FD4612, titled "Precast and Prestressed Lintel Details". sheet 1 of
<br />1, prepared by Craig Parrino, P. E_, dated March 24, 2003 and Drawing No.
<br />LT4612, titled"Cast-Crete 4 ", 6" & 12" Lintel Safe Load Tables'; sheets I
<br />through 3 of 3, prepared by Craig Parrino, P. E, dated March 24, 2003, last
<br />revision dated June 12, 2014, all signed and sealed by Craig Parrino, AE, on
<br />January 22, 20I R
<br />B, TESTS
<br />1. None.
<br />C. CALCULATIONS
<br />1. None.
<br />D. QUALITY ASSURANCE
<br />1. By ATami--Dade County Department of Regulatory and Economic Resources (RER).
<br />E. MATERIAL CERTIFICATIONS
<br />1. None.
<br />F. OTHER
<br />1. Article of Conversion for a name change.
<br />{
<br />my A. Makar, P.E., M.S.
<br />Product Control Section Supervisor
<br />NOA No. 204".15
<br />Expiration Date: 09/11/2023
<br />Approval Date. 0&20/2020
<br />E-4
<br />Cast -Crete USA�LLC
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUI3MITTEiI
<br />1. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL #03-0605.04
<br />A. DRAWINGS
<br />1. Drawing No. FD4612, titled "Precast and Prestressed Lintel Details ", sheet I of 4
<br />prepared by Craig Parrino, P.E., dated Mauch 24, 2003 and Drawing No. LT4612, titled
<br />"Cast -Crete 4" 6",& 12"Lintel Safe Load Tables", sheets 1 through 3 of 3, ,prepared by
<br />Craig Parrino, P.E., dated March 24, 2003, last revision #] dated April 2$ 2003 both
<br />drawings signed and sealed by Craig Perrino, P.F.
<br />B. TESTS
<br />4 Test report on flexural testing on 4 ", 6" & 12" Precast Concrete Lintels Filled and
<br />Willed Models, tmal of (13) concrete lintel specimens, per ASTM E-529-94, prepared
<br />by Applied Research Laboratories, Report No. 30404A, dated 04110103, signed and
<br />sealed by ChrlstopherA. FlamoA P.E.
<br />C. CALCULATIONS
<br />L Calculations for Cast -Crete Lintels, dated 05129103, 207pages, prepared by Craig
<br />Parrino, P.E., signed and sealed by Craig Parrino, P.E.
<br />a Calculations for Cast -Crete Lintels, dated 05129103, 140 pages, prepared by Craig
<br />Parrino. P.E., signed and sealed by Craig Parrino, A
<br />D. MATERIAL CERTIFICATION:
<br />1. Quality System Manual for Cast -Crete Machine Made Precast Lintels revised on May 1,
<br />2002.
<br />2 Cast -Crete Quality System Manual for Prestressed Products dated 2002.
<br />2. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 0"320.09
<br />A. DRAWINGS
<br />1. Drawing No. FD4612, titled "Precast and Prestressed Lintel Detaits", sheet 1 of 1,
<br />prepared by Craig Parrino, P.R. dated March 24, 2003 and Drawing No. LT4612, titled
<br />"Cast -Crete 4", 6" & 12" Lintel Safe Load Tables sheets I through 3 of 3, prepared by
<br />Craig Parrino, P.E., dated March 24, 2003, lastrevisiondated March 11, 2008.
<br />B. TESTS
<br />1. None.
<br />C. CALCULATIONS
<br />1. None:
<br />D. QUALITY ASSURANCE
<br />1. By Miami -Dade County Building Code Compliance Office.
<br />E. MATERIAL CERTIFICATIONS
<br />I. None.
<br />pi J. d. Aekl
<br />LepTieliny A. Makar, P.E., M.S.
<br />Proffuct Control Section Supervisor
<br />NOA No. 20.0630.1S
<br />Expiration Date: 09/11t2023
<br />Approval Date: 08t2011020
<br />E-1
<br />Cast -Crete U
<br />NOTICE OF ACCEPTANCE: EM-E-N- CE SUBMITTED
<br />9. NEW EVIDENCE SUBMITTED
<br />A. DRAWINGS
<br />1. None.
<br />B. TESTS
<br />1. None.
<br />C- CALCULATIONS
<br />1. None.
<br />D. QUALITY ASSURANCE
<br />1. By Miami Darde County Department of Regulatory and Economic Resources (RER);
<br />E. MATERIAL CERTIFICATIONS
<br />I_ None,
<br />F. OTHER
<br />1. Compliance Letter with the Florida Building Code, 2017Editim; issued by Cast -
<br />Crete USA, Inc, dated 08108117, signed & sealed by Craig Parrino, P.E.
<br />2. Compliance Letter with the Florida Building Code, 2020 Edition, issued by Cast -
<br />Crete USA, Inc., clued 0611112a signed & sealed by Craig Parrino, P.E
<br />Helmy A. Makar, P.E., M.S.
<br />Product Control Section Supervisor
<br />NOA No. 20-0630.15
<br />Expiration Date: 09/IVM3
<br />Approval Date: '000/2020
<br />E-5
<br />Cast Crete USA, LLC
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
<br />Cast -Crete USA, LLG
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
<br />3.
<br />EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 124209.12
<br />5.
<br />EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 14-0903.03
<br />A.
<br />DRAWINGS
<br />A.
<br />DRAWINGS
<br />1. Drawing No. FD4611, titled "Precast and Prestressed Lintel Details", sheet 1 of
<br />1. Drawing No. FD4612, titled "Precast and Prestressed Lintel Details'; sheet 1 of
<br />1, prepared by Craig Parrino, P.E., dated March 24, 2003 and Drawing No.
<br />1, dated 03124103 and Drawing No. LT4612, titled "Cast -Crete 4 ", 6" & 12"
<br />LT4612, titled "Cast -Crete 4 ", 6" & 12" Lintel Safe Load Tables", sheets 1
<br />Lintel Safe Load Tables ; sheets 1 through 3 of 3, last revision dated 06112114, all
<br />through 3 of 3, prepared by Craig Parrino, P.E,., dated March 24, 2003, last
<br />prepared, signed and sealed by Craig Perrino, AZ, on 08119114.
<br />revision dated March 11, 2008, all signed and sealed by Craig Parrino, P.E., on
<br />March 22, 2012.
<br />B.
<br />TESTS
<br />1. None.
<br />B.
<br />TESTS
<br />1. None.
<br />C.
<br />CALCULATIONS
<br />1. Calculations for Cost -Crete Lintels, dated 0811912014, pages 14.201 through 14.236,
<br />C.
<br />CALCULATIONS
<br />prepared by Craig Perrino, P.T , signed and sealed by Craig Parrino, RE,
<br />1. None.
<br />D.
<br />QUALITY ASSURANCE
<br />D.
<br />QUALITY ASSURANCE
<br />1. mi--D
<br />BY County Department of Regulatory and Economic Resources (RER).
<br />1. By ldiami Dade County Department of Permitting, Environment, and Regulatory Affau s.
<br />E.
<br />MATERIAL CERTIFICATIONS
<br />E.
<br />MATERIAL CERTIFICATIONS
<br />t. None
<br />1. None
<br />F
<br />OTHER
<br />F.
<br />OTHER
<br />1. Letter froth Cast -Crete USA, Inc, dated 081191M4, signed and sealed by Craig
<br />1. Letter from Cast -Crete Corporation, dated February 03, 2012, signed and sealed
<br />Parrino, P.E., certifying compliance with the Florida Building Code, 2014 Edition.
<br />by Craig Parrino, P. E, certifying compliance with the Florida Building Co*, 2010
<br />Edition
<br />6.
<br />EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 17-Ml.18
<br />A.
<br />DRAWINGS
<br />4.
<br />EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 1"321.07
<br />1. None.
<br />A.
<br />DRAWINGS
<br />B.
<br />TESTS
<br />1_ Nonce.
<br />1. None,
<br />R.
<br />TESTS
<br />1. None.
<br />C.
<br />CALCULATIONS
<br />1. None.
<br />C.
<br />CALCULATIONS
<br />D.
<br />QUALITY ASSURANCE
<br />1. Norte.
<br />1. By Mwmi-Dade Cowq Department of Regulattvy and Economic Resources (Em.
<br />D.
<br />QUALITY ASSURANCE
<br />1. By �ami-Dade County Department of Regulatory, and Economic Resources (RER).
<br />E.
<br />AID CERTIFICATIONS
<br />N
<br />None.
<br />1.. Non
<br />E.
<br />MATERIAL CERTIFICATIONS
<br />F.
<br />OTHER
<br />1. None.
<br />1. Compliance Letter with the Florida Building Code, 2017 Edition, issued by Cast -
<br />Crete USA, Inc.., dated 0&'08117, signed & sealed by Craig Parrino, AR
<br />elmy A. Malcar, P.E., M.S.
<br />� y A. MaMr, P.E., M %
<br />Product Control Section Supervisor
<br />Product Control Section Supervisor
<br />NOA No. 20-0630.iS
<br />NOA No. 20-0630.15
<br />Expiration Date: 09/11/2023
<br />Expiration Date; 09/ti1/2023
<br />Approval Date: OS/20/2020
<br />Approval Date: 09/20=0
<br />E-2
<br />E-3
<br />-#^—'a
<br />CD
<br />W
<br />Cn
<br />N
<br />Cu
<br />0
<br />.�.
<br />U
<br />CD
<br />C:)-
<br />0
<br />.�
<br />O
<br />c
<br />ca��
<br />.�
<br />U
<br />to
<br />C
<br />M
<br />0
<br />O
<br />to%
<br />U-
<br />CU
<br />-cn
<br />M
<br />-0
<br />a)"
<br />O
<br />a..
<br />07
<br />Q
<br />z
<br />z
<br />W
<br />J
<br />N
<br />rs
<br />N
<br />Go
<br />N
<br />c.�
<br />0
<br />i
<br />Cn
<br />Ca
<br />O
<br />CL
<br />CL
<br />Q
<br />May 27, 2022
<br />SHEET NO.
<br />PA 1 A
<br />
|