|
MIAMHIUX MtAMI-DADE COLNTY
<br />ffel 211 a= PRODUCT CONTROL SECTION
<br />DEPARTMENT OF REGULATORV AND ECONOMIC RESOURCES (RER) 11805 SW 26 Street, Room 208
<br />BOARD AND CODE ADMINISTRATION DIVISION Miami, Florida 33175-2474
<br />T (786) 315-2590 F (786) 315-2599
<br />NOTICE OF ACCEPTANCE (NOA) www.miomidade.aov/economy
<br />Cast -Crete USA, LLC
<br />6324 County Road 579
<br />Seffner, Florida 33584
<br />SCOPE:
<br />This NOA is being issued under the applicable rules and regulations governing the use of construction materials.
<br />The documentation submitted has been reviewed and accepted by Miami -Dade County RER- Product Control
<br />Section to be used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction
<br />(AHJ).
<br />This NOA shall not be valid after the expiration date stated below. The Miami -Dade County Product Control
<br />Section (In Miami Dade County) and/or the AHJ (in areas other than Miami Dade County) reserve the right to have
<br />this product or material tested for quality assurance purposes. If this product or material fails to perform in the
<br />accepted manner, the manufacturer will incur the expense of such testing and the AHJ may immediately revoke,
<br />modify, or suspend the use of such product or material within their jurisdiction. PER reserves the right to revoke
<br />this acceptance, if it is determined by Miami -Dade County Product Control Section that this product or material
<br />fails to meet the requirements of the applicable building code.
<br />This product is approved as described herein, and has been designed to comply with the High Velocity Hurricane
<br />Zone of the Florida Building Code.
<br />DESCREMON: (Cast -Crete) 4", 6" & 12" High Strength Precast and Prestressed Concrete Lintels
<br />APPROVAL DOCUMENT: Drawing No. FD4612, titled "Precast and Prestressed Lintel Details", sheet I of 1,
<br />prepared by Craig Parrino, P.E., dated March 24, 2003 and Drawing No. LT4612, titled "Cast -Crete 4", 6" & 12"
<br />Lintel Safe Load Tables", sheets I through 3 of 3, prepared by Craig Panino, P.E., dated March 24, 2003, last
<br />revision dated June 12, 2014, all signed and sealed by Craig Parrino, P.E., on January 22, 2019, all bearing the
<br />Miami -Dade County Product Control Revision stamp with the Notice of Acceptance number and the expiration
<br />date by the Miami -Dade County Product Control Section.
<br />MISSILE IWACTRATING: Large and Small Missile Impact Resistant
<br />LABELING: Each lintel shall bear a permanent label with the manufacturer's name or logo and the Miami -Dade
<br />County logo.
<br />RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no
<br />change in the applicable building code negatively affecting the performance of this product.
<br />TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
<br />materials, use, and/or manufacture of the product or process. Misuse of this NOA as an endorsement of any
<br />product, for sales, advertising or any other purposes shall automatically terminate this NOA. Failure to comply with
<br />any section of this NOA shall be cause for termination and removal of NOA.
<br />ADVERTISEMENT: The NOA number preceded by the words Nfiami-Dade County, Florida, and followed by
<br />the expiration date may be displayed in advertising literature. If any portion of the NOA is displayed, then it shall
<br />be done in its entirety.
<br />INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
<br />shall be available for inspection at thejob site at the request of the Building Official.
<br />This NOA revises NOA # 19-0130.14 and consists of this page 1, evidence submitted pages E- 1, E-2, E-3, E-4 and
<br />E-5 as well as approval document mentioned above.
<br />The submitted documentation was reviewed by Helmy A. Makar, P.E., M.S.
<br />MM"14MUM #4-3- �. NOA No. 20-0630.15
<br />Expiration Date- 09111/2023
<br />Approval Date: 08/20/2020
<br />Page I
<br />Cast -Crete USA, LLC
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
<br />1. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL #03-0605.04
<br />A. DRAWINGS
<br />1. Drawing No. FD4612, titled "Precast and Prestressed Lintel Details". sheet I of'].
<br />prepared ky Craig Parrino, P. F., dated March 24, 2003 and Drawing No. L T4612, titled
<br />"Cast -Crete 4 ", 6" & 12 " Lintel Safe Load Tables ", sheets I through 3 of 3, prepared by
<br />Craig Parrino, P. E., dated March 24, 2003. last revision #1 datedApril 28, 2003 both
<br />drawings signed and sealed by Craig Parrino, P. E.
<br />B. TESTS
<br />1. Test report onflexural testing on 4 ". 6 " & 12 - Precast Concrete Lintels Filled and
<br />Unfilled Models, total of (13) concrete lintel specimens, per ASTM E-529-94, prepared
<br />by Applied Research Laboratories, Report Alo. 30404A, dated 04,17 0103, signed and
<br />sealed by Christopher A. Hamon. P.E.
<br />C. CALCATLATIONS
<br />1. Calculationsfor Cast -Crete Liniels, dated 05129103, 207 pages, prepared kv Craig
<br />Parrino. P. E.. signed and sealed bY Craig Parrino, P. E.
<br />z Calculations for Cast -Crete Limels, dated 05129103, 140 pages, prepared by Craig
<br />Parrino. P. E., signed and sealed kv Craig Parrino, P. F,
<br />D. MATERIAL CERTIFICATION:
<br />1. Quality System Manualfor Cast -Crete Machine Made Precast Lintels revised on 11,fay 1.
<br />2002.
<br />2. Casi-Crete Qualit
<br />y,�ystem Manualfor Prestressed Products dated 2002.
<br />2. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 08-0320.09
<br />A. DRAWINGS
<br />1� Drawing No. FD4612, titled "Precast and Prestressed Lintel Details", sheet I of 1.
<br />prepared b - y Craig Parrino, P. E., dated March 24, 2003 and Drawing No. L T4612. titled
<br />"Cast -Crete 4 -, 6" & 12 " Lintel Safe Load Tables ", sheets I through 3 of 3, prepared by
<br />Craig Parrino. P. E., dated March 24, 2003, Iasi revision dated March 11, 2008.
<br />B. TESTS
<br />1. None.
<br />C. CALCULATIONS
<br />1. None.
<br />D. QUALITY ASSURANCE
<br />1. By Miami -Dade Count), Building Code Compliance Office.
<br />E. MATERIAL CERTIFICATIONS
<br />1. None.
<br />�imy Ma arP.E.,M.S.
<br />Proc4ruct Control Section Supervisor
<br />NOA No. 20-0630.15
<br />Expiration Date: 09/11/2023
<br />Approval Date: 08/20/2020
<br />E - I
<br />Cast -Crete USA, LLC
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
<br />3. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 12-0209.12
<br />A. DRAWINGS
<br />Dravving!Vo. FD4612, filled "Precast and Prestressed Lintel Details ", sheet I of
<br />1, prepared by Craig Parrino, P. E.. dated March 24, 2003 and Drawing No.
<br />LT4612, titled "Cast-Crele 4 ", 6 " & 12 " Lintel Safe Load Tables", sheets I
<br />through 3 of 3, prepared by Craig Parrino, P. E, dated March 24, 2003, last
<br />revision dated March 11, 2008, all signed and sealed by Craig Parrino, P.E., on
<br />March 22, 2012.
<br />B. TESTS
<br />1. None.
<br />C. CALCULATIONS
<br />I . None.
<br />D. QUALITY ASSURANCE
<br />L By Miami -Dade County Department of Permining, Environment. and Regulatory Affairs.
<br />E. MATERIAL CERTIFICATIONS
<br />1. None.
<br />F. OTHER
<br />1. Letter ftom Cast -Crete Corporation dated February 03, 2012, signed and sealed
<br />by Craig Parrino. P. E., cerfif�ing compliance w ith the F lorida Building Code, 2010
<br />Edition.
<br />4. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 13-0321.07
<br />A. DRAWINGS
<br />1. None.
<br />B. TESTS
<br />1, None.
<br />C. CALCULATIONS
<br />1. None.
<br />D. QUALITY ASSURANCE
<br />1. By Miami-Dode County Department of Reg7dalory and Economic Resources (RER).
<br />E. MATERIAL CERTIFICATIONS
<br />1. None.
<br />I I
<br />e my . Makar, P.E., M.S.
<br />Pro uct Control Section Supervisor
<br />NOA No. 20-0630.15
<br />Expiration Date: 09/11/2023
<br />Approval Date: 08/20/2020
<br />E-2
<br />Cast-Crcte L.SA. LLC
<br />I I -E SUBMITTED
<br />,NO FICE01f ACCEP-VANCF: EAJOENC
<br />F , N41)FNCE St.13MITTED I�NDFR PREVIO(I�S APPROVAL 4. 14-0903.03
<br />1) RA NN I NG S
<br />Dr, I, il i X0. 1, D4 612, , i I led 'T re ca s I and Prcslre.�.s ed 1, t n te i L )e I ci;ls shi - et I o f
<br />1, (io i rd 0 3/2 4!V 3 a nd Drai t, i r., A�o. 1,T4 612, 1 itled "Caw - Cre I c 4 12-
<br />Lini c I'Sule L oad Tab les ". she e I I hro ugh 3 ol 3, last re v isio i i dated 06, 1 1�1 4, all
<br />prepared, signed and seuledh.v Croig Parrino, P h,-, on 14,
<br />TESTS
<br />Aone.
<br />CALCULATIONS
<br />Calculationsfor (_asl-Crete Lintels. dated 08/1912014. pages 14. 201 through 14.236.
<br />preparred bY Cring Parrino, P L'.. signed and sealed b_v Cro�g Porrino, P. F.
<br />QLiAIATY ASSURAINCE
<br />I , i; - i kfiani i- Dade Couniv Department of'Regulatorlv ond E, onomic Resinjrcu.,i (R F--,R,,.
<br />NIATERExt. CERTIFICATIONS
<br />I None
<br />OTHII, , R
<br />I [eller �roln ("ost-Crele USA, Inc., daied 08119/2014, �igned and seuled ky Cll(lix
<br />PUrri.riu, P E. cert�AJ 1;11'(' c0l;ipbancc �Ii ith 1he Flor0a ( 70de, 2014 Eal'tion.
<br />LVIDENC4- St ' �BINIITTED UNDER PREVIOUS APPROVAL 4 17-0821.18
<br />DRAV-v INCS
<br />I Nonc
<br />"AIA14-ATIONS
<br />Nont,
<br />Q(JALiTi, ASSURANCE
<br />1;t:.tlwrni-l),jde County Oeparoncni ol_Regmluior� onflFconornic Re.,�our(,es (RER).
<br />M.A.-I'l-ORIAL CER FIFICATION'S
<br />1. IVOW.
<br />OTHER
<br />Compiance Lelier with the 1, forida Building Code, 201 -dition, ;ssiied 1) ' v Ca, I-
<br />Ci eilc 1,SA, Inc- dol(I-d 08 68 1 �s i-nedd., sealed bl, Cru�g Parrino 1) E
<br />L elmy A.Makar, P.E., M.S.
<br />Product ControlSection Supervisor
<br />NOA No. 20-0630.15
<br />Expiration Date: 09/11/2023
<br />Approval Date: 08t'2012020
<br />C-10
<br />>
<br />_C3
<br />(D
<br />0
<br />0
<br />CU
<br />U)
<br />a)
<br />.0
<br />U_
<br />M
<br />0
<br />0
<br />CZ
<br />#.-
<br />0
<br />>
<br />-0
<br />E
<br />(n
<br />a)
<br />C
<br />LO
<br />0-
<br />r
<br />Cn
<br />M
<br />_
<br />"o
<br />Co
<br />-#--a
<br />1
<br />-0
<br />.=
<br />C/)
<br />z
<br />z
<br />W
<br />mi
<br />Cgst-Crete USA, LLC Cast -Crete USA, LLC
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
<br />7. EVIDENCE SUBMIT'TED LTNDER PREVIOUS APPROVAL 18-0424.04 9. NEW EVIDENCE SUBMITTED
<br />A. DRAWINGS A. DRAWINGS
<br />1. None. 1. None.
<br />B. TESTS B. TESTS
<br />1. None. 1. None.
<br />C. CALCULATIONS C. CALCULATIONS
<br />1. None. 1. None.
<br />D. QUALITY ASSURANCE D. QUALITY ASSURANCE
<br />1. ByMiami-Dade County Department of Regulatory and Economic Resources (RER). L 4y Miami -Dade County Department of Regulatory and Economic Resources (RER)_
<br />E. MATERIAL CERTIFICATIONS E. MATERIAL CERTIFICATIONS
<br />L None. 1. None.
<br />F. OTHER F. OTHER C_
<br />1. Compliance Letter with the Florida Building Code, 2017 Edition, issued by Cast- 1. Compliance Letter with the Florida Building Code, 2017 E dilion, issued bv Cast- U)
<br />Crete USA, Inc-, dated 08108117, signed & sealed by Craig Parrino, P. E Crete USA, Inc., dated 08108117, signed & sealed by Craig Parrino, P. E.
<br />2. Compliance Letter with the Florida Building Code, 2020 Edition, issued by Cast- CU
<br />8. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL Al 19-0130.14 >
<br />A. DRAWINGS Crete USA, Inc., dated 06111120, signed & sealed by Craig Parrino, P. E. Co 0
<br />1. Drawing No. FD4612, titled "Precast and Prestressed Lintel Details", sheet I of CL
<br />1, prepared by Craig Parrino, P. E., dated March 24, 2003 and Drawing No. > 0-
<br />LT4612, titled "Cast -Crete 4 ", 61' & 12 -Lintel Safe Load Tables", sheets I <
<br />through 3 of3. prepared by Craig Parrino, P. E., dated March 24, 2003, last -6-0
<br />revision dated June 12, 2014, all signed and sealed by Craig Parrino, P. E., on 0
<br />January 22, 2019. =3
<br />B. TESTS 0
<br />1. None.
<br />C. CALCULATIONS
<br />1. None.
<br />D. QUALITY ASSURANCE
<br />1. By Miami -Dade County Department of Regulmory and Economic Resources (RER). MAR 25 2M
<br />E. MATERIAL CERTIFICATIONS
<br />1. None.
<br />F. OTHER
<br />1. Article of Conversionfor a name change. VV'
<br />Virtual Review A sist. Inc. 0
<br />S UJ
<br />lete aj
<br />Plans Review complet p r
<br />d and ap r ed
<br />for compliance with the 2020 FBC 7th Edition (3)
<br />C*Yemy A. Makar, P.E, M.S. �7 Helmy A. Makar, P.E., M.S.
<br />Product Control Section Supervisor Product Control Section Supervisor by Debra Anne Klahr PX2300 _J
<br />NOA No. 20-0630.15 NOA No. 20-0630.15
<br />Expiration Date: 09/11/2023 Expiration Date: 09/1112023 <
<br />Approval Date: 08/20/2020 Approval Date: 09/20/2020 _J
<br />E-4 E-5
<br />SHEET NO.
<br />PA 1.51
<br />
|