|
MIAM� MIAMI-DADE COUNTY
<br />PRODUCT CONTROL SECTION
<br />D ki
<br />EPARTMENT OF REGULATORY AND ECONOMIC RESOURCES (RER) 11805 SW 26 Street, Room 208
<br />BOARD AND CODE ADMINISTRATION DIVISION Miami, Florida 33175-2474
<br />T (786) 315-2590 F ('786) 315-2599
<br />NOTICE OF ACCEPTANCE (NOA) M=.m ism idadt.lov/economy
<br />Cast -Crete USA, LLC
<br />6324 County Road 579
<br />Seffner, Florida 33584
<br />SCOPE:
<br />This NOA is being issued under the applicable rules and regulations governing the use of construction materials.
<br />The documentation submitted has been reviewed and accepted by Miami -Dade County RER- Product Control
<br />Section to be used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction
<br />(AHJ).
<br />This NOA shall not be valid after the expiration date stated below. The Miami -Dade County Product Control
<br />Section (In Miami Dade County) and/or the AHJ (in areas other than Miami Dade County) reserve the right to have
<br />this product or material tested for quality assurance purposes. If this product or material fails to perform in the
<br />accepted manner, the manufacturer will incur the expense of such testing and the AHJ may immediately revoke,
<br />modify, or suspend the use of such product or material within their jurisdiction. RER reserves the right to revoke
<br />this acceptance, if it is determined by Miami -Dade County Product Control Section that this product or material
<br />fails to meet the requirements of the applicable building code.
<br />This product is approved as described herein, and has been designed to comply with the High Velocity Hurricane
<br />Zone of the Florida Building Code.
<br />DESCRIPTION: (Cast -Crete) 4", 6" & 12" High Strength Precast and Prestressed Concrete Lintels
<br />APPROVAL DOCUMENT; Drawing No. FD4612, titled "Precast and Prestressed Lintel Details", sheet I of 1,
<br />prepared by Craig Parrino, P.E., dated March 24, 2003 and Drawing No. LT4612, titled "Cag-Crete 4", 6" & 12's
<br />Lintel Safe Load Tables", sheets I through 3 of 3, prepared by Craig Parrino, P.E., dated March 24, 2003, last
<br />revision dated June 12, 2014, all signed and sealed by Craig Parrino, P.E., on January 22, 2019, all bearing the
<br />Miami -Dade County Product Control Revision stamp with the Notice of Acceptance number and the expiration
<br />date by the Miami -Dade County Product Control Section.
<br />MISSILE IMPACT RATING: Large and Small hfissile Impact Resistant
<br />LABELING: Each lintel shall bear a permanent label with the manufacturees name or logo and the Miami -Dade
<br />County logo.
<br />RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no
<br />change in the applicable building code negatively affecting the performance of this product.
<br />TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
<br />materials, use, and/or manufacture of the product or process. Misuse of this NOA as an endorsement of any
<br />product, for sales, advertising or any other purposes shall automatically terminate this NOA. Failure to comply with
<br />any section of this NOA shall be cause for termination and removal of NOA.
<br />ADVERTISEMENT: The NOA number preceded by the words Miami -Dade County, Florida, and followed by
<br />the expiration date may be displayed in advertising literature. If any portion of the NOA is displayed, then it shall
<br />be done in its entirety.
<br />INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
<br />shall be available for inspection at thejob site at the request of the Building Official.
<br />'Mis NOA revises NOA # 19-0130.14 and consists of this page 1, evidence submitted pages E- 1, E-2, E-3, E4 and
<br />E-5 as well as approval document mentioned above.
<br />The submitted documentation was reviewed by Helmy A. Malcar, P.E., M.S.
<br />NOA No. 204WO.15
<br />JAPPROVEDI- Expiration Date: 09/11/2023
<br />Approval Date: 08/20/2020
<br />Page I
<br />Cast -Crete USA, LLC
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
<br />1. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL #03-0605.04
<br />A. DRAWINGS
<br />1. Drawing No. FD4612, titled "Precast and Prestressed Lintel Details " sheet I of 1,
<br />prepared by Craig Parrino, P.E., dated March 24,2003andDrawing No. LT4612, titled
<br />"Cast-Crete4", 611& 12" Lintel Safe Load Tables". sheets I through 3qf3,prepared by
<br />Craig Parrino, P.E., dated March 24, 2003, last revision #1 datedApril 28, 2003 both
<br />drawings signed and sealed by Craig Parrino, P. E.
<br />B. TESTS
<br />1. Test report onflexural testing on 4 ", 6" & 12 " Precast Concrete Lintels Filled and
<br />Unfilled Models, total of (13) concrete lintel spec imens, per A STM E-52 9- 94, prepared
<br />by Applied Research Laboratories, Report No. 30404A, dated 04110103, signed and
<br />sealed by Christopher A. Hamon, P. E.
<br />C. CALCULATIONS
<br />1. Calculationsfor Cast -Crete Lintels, dated 05129103, 20 7 pages, prepared by Craig
<br />Parrino, P.E., signed and sealed by Craig Parrino, P.E.
<br />2. Calculations for Cast -Crete Linlels, dated 05129103, 140 pages, prepared by Craig
<br />Parrino, P.E., signed and sealed by Craig Parrino, P.E.
<br />D. MATERIAL CERTIFICATION:
<br />1. Quality System Manualfor Cast -Crete Machine Made Precast Lintels revised on May 1.
<br />2002.
<br />z Cast -Crete Quality System Manualfor Prestressed Products dated 2002.
<br />2. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 08-0320.09
<br />A. DRAWINGS
<br />1. Drawing No. FD461Z titled "Precast and Prestressed Lintel Details", sheet I of 1,
<br />prepared by Craig Parrino, P.E., dated March 24, 2003 and Drawing No. LT4612, titled
<br />"Cast -Crete 4 ", 6" & 12 " Lintel Safe Load Tables", sheets I through 3 of 3, prepared by
<br />Craig Parrino, P.E., dated March 24, 2003, last revision dated March 11, 2008.
<br />B. TESTS
<br />1. None.
<br />C. CALCULATIONS
<br />1. None.
<br />D. QUALITY ASSURANCE
<br />1. By Allami-Dade County Building Code Compliance Office.
<br />E. MATERIAL CERTIFICATIONS
<br />1. None.
<br />,/J. ze__ -
<br />Aeilimy'A. Makar, P.E., M.S
<br />ontrol Section Superviso;
<br />NOA No. 20-0630.15
<br />Expiration Date: 09/11/2023
<br />Approval Date: 0&70/2020
<br />E-1
<br />Cast -Crete USA, LLC
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
<br />3. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 12-0209.12
<br />A. DRAWINGS
<br />1. Drawing No. FD4612, filled "Precast and Prestressed Lintel Details ", sheet I of
<br />1, prepared by Craig Parrino, P. E., dated March 24, 2003 and Drawing No.
<br />LT4612, titled "Cast -Crete 4 ", 6" & 12 " Lintel Safe Load Tables", sheets I
<br />through 3 of3, prepared by Craig Parrino, P. E., dated March 24, 2003, last
<br />revision dated March 11, 2008, all signed and sealed by Craig Parrino, P.E., on
<br />March 22, 2012.
<br />B. TESTS
<br />1. None.
<br />C. CALCULATIONS
<br />1. None.
<br />D. QUALITY ASSURANCE
<br />1. By Miami -Dade County Department of Permitting, Environment, and RegulatoryAffairs.
<br />E. MATERIAL CERTIFICATIONS
<br />1. None.
<br />F. OTHER
<br />1. Letter from Cast -Crete Corporation, dated February 03, 2012, signed and sealed
<br />by Craig Parrino, P. E., certifying compliance with the Florida Building Code, 2010
<br />Edition-
<br />4. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 13-0321.07
<br />A. DRAWINGS
<br />1. None.
<br />B. TESTS
<br />1. None.
<br />C. CALCULATIONS
<br />1. None.
<br />D. QUALITY ASSURANCE
<br />1. By Miami -Dade County Department of Regulatory and Economic Resources (RER).
<br />E. MATERIAL CERTIFICATIONS
<br />1. None.
<br />elmy A. Makar, P.E., M.S.
<br />ol Section Supervisor
<br />NOA No. 20-0630.15
<br />Expiration Date: 09/11/2023
<br />Approval Date: 09/20/2020
<br />E-2
<br />Cast -Crete USA, LLC
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
<br />5.
<br />EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 14-0903.03 U0
<br />A.
<br />DRAWINGS owl
<br />1. Drawing No. FD4612, titled "Precast and Prestressed Lintel Details 'I, sheet I of.-w-
<br />],dated 03124103 and Drawing No. LT4612, titled "Cast -Crete 4 ", 61, & 12
<br />Lintel Safe Load Tables sheets I through 3 of3, last revision dated 06112114,
<br />ar
<br />6C,
<br />prepared signed and sealed by Craig Parrino, P. E., on 08119114.
<br />C,',4
<br />B.
<br />TESTS
<br />I . None.
<br />C.
<br />CALCULATIONS
<br />3; -51. X-
<br />P. -
<br />1. Calculationsfor Cast -Crete Lintels, dated 0811912014, pages 14.201 through 14.236,
<br />C;
<br />W 0=:
<br />prepared by Craig Parrino, P. E., signed and sealed by Craig Parrino, P. E.
<br />D.
<br />QUALITY ASSURANCE
<br />cc
<br />1. By Miami -Dade County Department of Regulatory and Economic Resources (RER).
<br />E.
<br />MATERIAL CERTIFICATIONS
<br />1. None.
<br />F.
<br />OTHER
<br />1. Letter from Cast -Crete USA, Inc., dated 0811912014, signed and sealed by Craig
<br />Parrino, P.E., certifying compliance with the Florida Building Code, 2014 Edition.
<br />6.
<br />EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 17-0821.18
<br />A.
<br />DRAWINGS
<br />1. None.
<br />B.
<br />TESTS
<br />1. None.
<br />C.
<br />CALCULATIONS
<br />1. None.
<br />D.
<br />QUALITY ASSURANCE
<br />1. By Miami -Dade County Department of Regulatory and Economic Resources (RER).
<br />E.
<br />MATERIAL CERTIFICATIONS
<br />1. None.
<br />F.
<br />OTHER
<br />1. Compliance Letter with the Florida Building Code, 2017 Edition, issued by Cast -
<br />Crete USA, Inc., dated08108117, signed& sealed by Craig Parrino, P.E.
<br />" J� Ayc_� I
<br />g5>1HIefiny A. Makar, P.E., M.S.
<br />Product Control Section Supervisor
<br />NOA No. 20-0630.15
<br />Expiration Date: 09/IV2023
<br />Approval Date: 08/20/2020
<br />E-3
<br />Cn
<br />-0
<br />>
<br />0
<br />(D
<br />Ca-
<br />0
<br />2
<br />Cd
<br />-0
<br />CIO
<br />V5
<br />0
<br />2
<br />25-
<br />0
<br />3r.
<br />CU
<br />0
<br />CIO
<br />LL
<br />'I
<br />0
<br />—
<br />CU
<br />>
<br />.00
<br />CO
<br />E
<br />L_
<br />2
<br />ca.
<br />_E
<br />CwU
<br />Cl)
<br /><
<br />z
<br />z
<br />W
<br />=I
<br />Cast -Crete USA, LLC
<br />Cast -Crete USA,, LLC
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBM[ITTED
<br />7. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 18-0424.04
<br />9. NEW EVIDENCE SUBMITTED
<br />A. DRAWINGS
<br />A. DRAWINGS
<br />1. None.
<br />1. None.
<br />B. TESTS
<br />B. TESTS
<br />1. None.
<br />1. None.
<br />C. CALCULATIONS
<br />C. CALCULATIONS
<br />1. None.
<br />1. None.
<br />D. QUALITY ASSURANCE
<br />D. QUALITY ASSURANCE
<br />1. By Miami -Dade County Department of Regulatory and Economic Resources (RER).
<br />1. By Miami -Dade County Department of Regulatory and Economic Resources (RER).
<br />E
<br />E. MATERIAL CERTIFICATIONS
<br />E. MATERIAL CERTIFICATIONS
<br />1. None.
<br />1. None.
<br />=:3
<br />F. OTHER
<br />F. OTHER
<br />1. Compliance Letter with the Florida Building Code, 2017 Edition, issued by Cast-
<br />1. Compliance Letter with the Florida Building Code, 2017 Edition, issued by Cast-
<br />z
<br />U)
<br />Crete USA, Inc., dated 08108117, signed & sealed by Craig Parrino, P. E.
<br />Crete USA, Inc., dated 08108117, signed & sealed by Craig Parrino, P. E
<br />C0
<br />8. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 19-0130.14
<br />2. Compliance Letter with the Florida Building Code, 2020 Edition, issued by Cast-
<br />>
<br />A. DRAWINGS
<br />Crete USA, Inc., dated 06111120, signed& sealed by Craig Parrino, P. E.
<br />0
<br />1. Drawing No. FD4612, titled "Precast and Prestressed Lintel Details ", sheet I of
<br />>
<br />L_
<br />1, prepared by Craig Parrino, P. E., dated March 24, 2003 and Drawing No.
<br />LT4612, titled "Cast -Crete 4 ", 6" & 12 " Lintel Safe Load Tables ", sheets 1
<br />0
<br /><
<br />through 3 of3, prepared by Craig Parrino, P. E., dated March 24, 2003, last
<br />revision dated June 12, 2014, all signed and sealed by Craig Parrino, P. E., on
<br />January 22, 2019.
<br />B. TESTS
<br />0
<br />1. None.
<br />C. CALCULATIONS
<br />1. None.
<br />D. QUALITY ASSURANCE
<br />CIO
<br />ca
<br />1. By Miami -Dade County Department of Regulatory and Economic Resources (RER).
<br />E. MATERIAL CERTIFICATIONS
<br /><
<br />1. Mone.
<br />F. OTHER
<br />1. Article of Conversionfor a name change.
<br />CC
<br />LU
<br />041eliny A. Makar, PI M.S.
<br />Cl- Heliny A. Makar, P.E., M.S.
<br />< (D
<br />Z
<br />Product Control Section Supervisor
<br />Product Control Section Supervisor
<br />NOA No. 20-0630.15
<br />NOA No. 20-0630.15
<br />z
<br />Expiration Date: 09/11/2023
<br />Expiration Date: 09/11/2023
<br /><
<br />Approval Date: 08/20/2020
<br />Approval Date: 08/20/2020
<br />_J
<br />E-4
<br />E-5
<br />CL
<br />November 1, 2023
<br />SHEET NO.
<br />PA 1.5
<br />
|