|
MIAMh MIAMI-DADE COUNTY
<br />6-AWAUM PRODUCT CONTROL SECTION
<br />DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES (RER) 11805 SW 26 Street. Room 208
<br />BOARD AND CODE ADMINISTRATION DIVISION Miarni, Florida 331'75-2474
<br />T (786) 315-25!M F (M) 315-2599
<br />NOTICE OF ACCEPTANCE _ www.miatnidade.govleconomv
<br />Cast -Crete USA, LLC
<br />6324 County Road 579
<br />Seffner, Florida 33584
<br />SCOPE:
<br />1-his NOA is being issued under the applicable rules and regulations governing the use of construction materials.
<br />The documentation submitted has been reviewed and accepted by Miami -Dade County RER- Product Control
<br />Section to be used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction
<br />(AHJ).
<br />`I'his NOA shall not be valid after the expiration date stated below. The Miami -Dade County Product Control
<br />Section In Miami Dade County) and/or the AHJ in areas other than Miami Dade County) reserve the Tight to have
<br />this product or material tested for quality assurance purposes. If this product or material fails to perform in the
<br />accepted manner, the manufacturer will incur the expense of such testing and the AFIJ may immediately revoke,
<br />modify, or suspend the use of such product or material within their jurisdiction. RER reserves the right to revoke
<br />this acceptance, if it is determined by Miami -Dade County Product Control Section that this product or material
<br />fails to meet the requirements of the applicable building code,
<br />-Ibis product is approved as described herein, and has been designed it) comply with the High Velocity I lurricalle
<br />Zone of the Florida Building Code,
<br />DESCRIPTION: ( Cast -Crete) 4", 6" & 12" High Strength Precast and Prestressed Concrete Lintels
<br />APPROVAL DOCUMENT: Drawing No- FD4612, titled "Precast and Prestressed Untel Details". sheet I of 1,
<br />prepared by Craig Parrino, P.E., dated March 24, 2003 and Drawing No. LT4612, titled "Cast -Crete 4". 6" & 12-
<br />Lintel Safe Load Tables", sheets I through 3 of 3, prepared by Craig Parrino, P.P., dated March 24. 2003, last
<br />revision dated June 12, 2014, all signed and sealed by Craig Parrines, RE,, on January'22. 2019, all bearing the
<br />Miarni-Dade County Product Control Revision stamp with the Notice of Acceptance number and the expiration
<br />date by the Miami -Dade County Product Control Section,
<br />MISSILE IMPACT RATING: Large and Small Missile Impact Resistant
<br />LABELING. Each lintel shall bear a permanent label with die manufacturer's name or logo and the Miami -Dade
<br />County logo.
<br />RENEWAL of this NOA shall be considered after a renewal application has been tiled and there has been no
<br />change in the applicable building code negatively affecting the performance of this pro -duct,
<br />TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
<br />materials, use, and/or manufacture of the product or process. Misuse of this NOA as an endorsement of any
<br />product, for sales, advertising or any other purposes shall automatically terminate this NOA. Failure to comply with
<br />any section of this NOA shall be cause for termination and removal of NOA_
<br />ADVERTISEMENT: The NOA number preceded by the words Miami -Dade County. Florida. and followed by
<br />the expiration date may be displayed in advertising literature. If any portion of the N& is displayed, then it shall
<br />be done in its entirety.
<br />INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
<br />shall be available for inspection at the job site at the request of the Building Official.
<br />This NOA revises NOA # 19-0130.14 and consists of this page 1, evidence submitted pages P-IE E-1 E-3. E-4 and
<br />E-5 as well as approval document mentioned above,
<br />The submitted documentation was reviewed by Helmy A. Makar, P.E., M.S.
<br />NOA No, 20-0630.15
<br />Expiration Date. 09111/2023
<br />Approval Date- 08120/21020
<br />Page I
<br />Cast -Crete USA, LLC
<br />NOTICE OF ACCEPTANCE. EVIDENCE SUBMITTED
<br />7. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 18-0424.04
<br />A. DRAWINGS
<br />L -None.
<br />B. TESTS
<br />1. None.
<br />C. CALCULATIONS
<br />1. None.
<br />D. QUALITY ASSURANCE
<br />1. By ?Miami -Dade Count), Department of'Regularory and Economic Resources (RER).
<br />F. MATERIAL CERTIFICATIONS
<br />1, None.
<br />F. OTHER
<br />L Compliance Letter with the Florida Building Code, 2017 Edition. issued by Cast -
<br />Crete U'S4. Inc.. dated 081( )8,('l 7, signed &- sealed by Craig Parrino. P. E.
<br />8. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 19-0130.14
<br />A. DRAWINGS
<br />1. Drawing N"o, FD4612, titled "Precast and Prestressed Lintel Details" sheet I of
<br />1, preiyared by Craig Parrino, P. E_ (titled March 24, 2003 and Drawing No,
<br />LT4612. titled "Cast -Crete 4 ", 6" & 12." Lintel Safi? Load Tables" sheets I
<br />through 3 o0. prel)ared by Craig Parrino, P. E_ dated1farch 24, 2003, last
<br />revision dated June 12 2014, all signed and scaled by Craig Parrino. P. K . on
<br />January 22, 2019.
<br />B. TESTS
<br />1, N'one.
<br />C. CALCULATIONS
<br />1. Vone,
<br />M QUALITY ASSURANCE
<br />I By Alianii-Dade County Department of Regulators: and'Ecanomic Resources (RER)
<br />E. MATERIAL CERTIFICATIONS
<br />1. None.
<br />F. OTHER
<br />I. Article of Conversionfor a narne change,
<br />C*e MY A. Makar, P.C., M.S.
<br />Product Control Section Supervisor
<br />NOA No. 20-0630.15
<br />Expiration Date: 09/11/2023
<br />Approval Date: 08/20/2020
<br />E-4
<br />Cast Crete USA, LLC
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
<br />1. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL #03-0605.04
<br />A. DRAWINGS
<br />1. Drawin�g No FD4612, titled "Precast and Presiressed Lintel Details sheet I fifl,
<br />prepared ky -Craig Parrino. P. E., dated ,Vlarch 24. 2003 ndlnannr�if Alo, L 7-4612, iiiied
<br />"Fast -Crete 4 ". 6 1.1 " Lintel Sate Load Tables ", sheets 1 thraugh 3 of 3, prepared 4
<br />Crai-,- Parrino, P-E., dated March 24. 2003, last revision ff'l elated April 2S, 12003 both
<br />drawings signed anti sealed by Crui,Q Parrinu, R E
<br />B. TESTS
<br />1. Test report on flexural resting on 4 ", 6 12 '' Precast Concrete lintels Fit&d arid
<br />Unfilled itlodels, wral of (13) cancrete linteispecunens, per AS11f F-5 prepared
<br />by Applied Research Laboratories. Report A'o- 3Cl404A, dated 04 10!03, .% igned and
<br />sealed by Christopher A. 11anion, P. 1a
<br />C. CALCULATIONS
<br />1. Calculation-v - for Cast -Crete Lintels, dated 05,29/03, 20 /7 pagcs, prepared hy Crai,,
<br />Parrino, P E.. signed rind sealed by Crarz Parrim.i. P.E.
<br />2. Caiculaiions for C'ast-Crete Lintels, drued 0''!1 03, 140 pa,es, pree pared hY Crakiz
<br />Parrino, R E., signed and sealed its, Craig Parrine.. 1, E.
<br />D. MATERIAL CERTIFICATION-
<br />jt4anualair .Ifzclvne 147,ic Pi-ecasi 1 hn,4v revived on Akil, 1.
<br />2002.
<br />2. Cast -Crete Quality System.,11anual V _1br Prestre, sed Products dated �00
<br />2. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 08-0320,09
<br />A. DRAWINGS
<br />L Drawing No. FD4612. titled "Precast and Prestressed Lintel Details", sheel I cy' 1,
<br />prepared by Craig Parrino, P.E., dated.klarch 24, 2603 and Draorin� i?_ 1,174612, titled
<br />"Cast -Crete 4 ", 6" & 12" Lintel Safe Load fables", sheets I through of 3. prepared by
<br />CraigParrino. RE. dated.Uarch 24. 20031 hvt revision dated March 1.1, 2008,
<br />B. TESTS
<br />1. None.
<br />C. CALCULATIONS
<br />1. ,Vone.
<br />D. QUALITY ASSURANCE
<br />1. By kfiami-Dade County Building Code Compliance (yfice.
<br />E. MATERIAL CERTIFICATIONS
<br />1, None,
<br />4elmy A. Makar. P.E., M.S.
<br />Product Control Section Supervisor
<br />NOA No. 20-0630,1,-,
<br />Expiration Date: 09/11/2023
<br />Approval Date: 04/20/2020
<br />E - I
<br />Cast -Crete USA, LLC
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
<br />9. NEW EVIDENCE SUBMITTED
<br />A. DRAWINGS
<br />1. None.
<br />B. TESTS
<br />L None.
<br />C. CALCULATIONS
<br />1. None-
<br />D. QUALITY ASSURANCE
<br />1, Bv.kliami-Dade County Deparnnent of Regulatorl, andEcon(nnic Resources tRER).
<br />E. MATERIAL CERTIFICATIONS
<br />1, Nonc.
<br />F, OTHER
<br />1, Compliance Letter- with the Flin-14141 BuildhW Code, 201 / Edition. Lsned by Casl-
<br />Crete t,`SA, Inc,, dated 08-10.40 _7. s i gneed & sealed b.v Craig Parrino, P E
<br />Compliance Letter with the Florida Buildin; Code, 2020 Editionissued h `V Cast -
<br />Crete USA Inc-, dated 06/11120- signed & sealed by Crai.st, Parrino, P /--I
<br />14,
<br />Helmv A. Makar, P.C., M.S.
<br />Product Control Section Supervisor
<br />NOA No. 20-0630.15
<br />Expiration Date: 09VI 112023
<br />Approval Date: 08,120/2020
<br />E-5
<br />Cast -Crete USA, LLC
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
<br />Cast -Crete USA, LLC
<br />NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
<br />3.
<br />EVIDEN( ' 'L, E SUBMITTED UNDER PREVIOUS APPROVAL # 12-0209.12
<br />5,
<br />EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 14-0903.03
<br />A.
<br />DRAWINGS
<br />A.
<br />DRAWINGS
<br />I DrawingNoFD4612, titled "Precast and Prestressed Lintel Details", sheet I
<br />1, Drarving No. FD4612, titled "Precast and Prestressed Lintel Details", sheet I of
<br />1, prepared late ' Craig Parrino. P, E., datedAlarch 24, 2003 and DrasvN itW o,
<br />1, dated 03124,V3 and Drawing No. LT4612, titled "Cast -Crete 4 ", 6 11 & 12 "
<br />LT461 2, titled "Cast -Crete 4 ', 6" 12 " Lintel Sqk Load Tables ", sheets I
<br />LinlelSae Load Tables", sheets I through 3 of3, last revision doled 06/12114, all
<br />throat 3 of'3, prepared by Craig Parrino, P. K. dented ;1 24. 2003. last
<br />preixtred, signed and scaled by Craig Parrino, P. E. on 08/19114.
<br />revisions dated.klarch 11, -7008, all signed and sealed by Craig Parrino, P. E, on
<br />Aforch.'.22, 2:012-
<br />B.
<br />TESTS
<br />I. None,
<br />B.
<br />TESTS
<br />1. Mone.
<br />C.
<br />CALCULATIONS
<br />1. Calculations.lbr Cast -Crete Lintels, dated 08119.12014, pages 14.201 through 14.236,
<br />C.
<br />C'ALCULATIONS
<br />prepared by (.7raig Parrino, RE, signed and sealed b), Craig Parrino, P. E.
<br />1. N'One.
<br />D.
<br />QUALITY ASSURANCE
<br />D.
<br />QUALITY ASSURANCE
<br />1. By Miami -Dade Con 4, Department ql'Regulatory and Fxonomic Resources (RER).
<br />1, Bit Miami -Dade Corintv Deparnneni 0/ Pernritting. Environment, and Regulatory Affi7irs.
<br />E.
<br />MATERIAL CERTIFICATIONS
<br />E.
<br />MATERIAL CERTIFICATIONS
<br />L None.
<br />F.
<br />OTHER
<br />F,
<br />OTHER
<br />L Letter from Cast-Crele USA, Inc., dated 0811912014, signed and sealed by Craig
<br />L Letter ftonz Ca.vt-Crele Corporation, dated FI-1hruary 03, 2012, signed and sealed
<br />Parrino, P.E., certJfing comi)liance with the Florida Building Cnde, 2014 Edition.
<br />ky Craig Parrino, P.E_.. certi&in�z compliance vvith the Florida Building Code, 2010
<br />E'dilion
<br />6.
<br />EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 17-0821.18
<br />A.
<br />DRAWINGS
<br />4.
<br />EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL # 13-0321.07
<br />1. None.
<br />A.
<br />DRAWINGS
<br />1. Alone,
<br />B.
<br />TESTS
<br />1. None.
<br />B.
<br />TESTS
<br />1. None.
<br />C.
<br />CALCULATIONS
<br />L None.
<br />C.
<br />CALCULATIONS
<br />L None,
<br />D.
<br />QUALITY ASSURANCE
<br />1. By Miami -Dade County Department of Regulatory and Economic Resources (RER).
<br />D.
<br />QUALITY ASSURANCE
<br />E.
<br />MATERIAL CERTIFICATIONS
<br />1, Rvkliaini-Dadv Cowin,, Department (?f Regulator"[�. "and cn oomic Resources (RER).
<br />1. None.
<br />E.
<br />MATERIAL, CERTIFICATIONS
<br />F.
<br />OTHER
<br />1. None,
<br />1. Coml)liance Letter with the Florida Building Code, 2017 Edition, issued b)i Cast -
<br />Crete USA Inc., dated 08108117, signed & sealed by Craig Parrino, P. E.
<br />0
<br />Alelniv A. Makar, P.E., KS.
<br />C./Helroy A. akar, P.E., M.S.
<br />Product Control Section Supervisor
<br />Product Control Section Supervisor
<br />NOA No. 20-0630.15
<br />NOA No, 20-0630.15
<br />Expiration Date: 09/1112023
<br />Expiration Date: 09/1112023
<br />Approval Date. 08/20/2020
<br />Approval Date: 08/2012020
<br />E-3
<br />hW S
<br />.I UPS Ki p's� and 31
<br />4, a\J I . , I F , 0, ,
<br />\Tlrtus� coip�_ '.. ,, F13C
<br />e\jlew U,� Q ').300
<br />pw\s ce '\allif Py�--
<br />Ed..00
<br />t o►PVlaby nebTa Anne y
<br />lt
<br />May 27, 2022
<br />-6-0
<br />CD
<br />C_
<br />Cn
<br />_0
<br />-Cu
<br />>
<br />a)
<br />C-
<br />'0
<br />2
<br />I =
<br />0
<br />"
<br />2
<br />,0)
<br />a)
<br />EL
<br />CU
<br />0,
<br />-010-
<br />-
<br />(D
<br />-4-
<br />U)
<br />O
<br />=3
<br />CU
<br />-
<br />CU
<br />U)
<br />5
<br />-0
<br />-0
<br />0
<br />CU
<br />>
<br />Cn
<br />.-
<br />-0
<br />E
<br />2
<br />Cn
<br />!E
<br />(D
<br />2.
<br />C:)
<br />C/)
<br />ca-
<br />all
<br />4
<br />z
<br />z
<br />W
<br />J
<br />O
<br />CU
<br />>
<br />0 L_
<br />0
<br />0
<br />Cl)
<br />ICU
<br />O
<br />W
<br />z
<br />_J
<br />CL
<br />SHEET NO.
<br />PA 1.4,
<br />
|