|
<br />SINGLE HUNG
<br />
<br />G
<br />
<br />~
<br />
<br />I
<br />
<br />A-.J ELFVATiON
<br />
<br />MASONRY (FLANGE)
<br />
<br />B.w,
<br />(BUCK 'w:t,,,) l
<br />/~ ONE BY wOOD INSTAlLA T!JN ANCHOR t'
<br />~ BUCK BY OTHERS 3/16' DrA. TAPPE:R-
<br />:NO'-E 5 ~ 7) (~O'E I,,)
<br />S"!" AS REQ'D, I' ,
<br />:/4' MAX \
<br />RIGlJ VINYL (S(E ~OrES) I
<br />GLAZING BEAD __ \
<br />(TYP ) ____________
<br />&l ~ \\~-,
<br />Lbl\7\ 0
<br />FLANGE TYPE ~~/r
<br />\.... INJOIN rRA~E
<br />..M~B ~~~~~'Na~L~~6i ! i
<br />~ wOaD BUCK PERiMt:TER1AI )'
<br />CAULK .J
<br />11.'-' BY OTf-'ERS I.
<br />(,"INDO\ol ',!D-") /" \
<br />S"'ucco B'r' eTHERS ~ CAULK BE:T\lEE~
<br />~~~~~~:\J~~MNG SFCTiON 8-8 ;t;~~ 3CJUpcE~ItG
<br />:BY CTi-<~~S ,By C-H[RS
<br />
<br />IMPORTANT INFORMATION llt GENERAL NOTES
<br />These notes are provided to eosure proper installaboo. of Flor'ca Extruders 1oIi1e,ione
<br />products and must be followed fully.
<br />
<br />----......jH/4. i'lt"j.1
<br />[M3(DME:,,,<T ;-
<br />
<br />GENERAL INSTALLATION INSTRUCTIONS
<br />
<br />>
<br />
<br />I 1) SHIM AS REQ'D. AT EACH INSTAll.AT10N ANCHOR WlTI~ LOAD BEARING SHIM. MAX.
<br />ALLOWABLE SHIM STACK TO BE 1/4".
<br />2) USE SIUCO'llZED ACRYUC CAULK BEHIND WINDOW FLA'K>E AT HEAO 8< JAMBS,
<br />SILL MUST BE ATTACHED TO THE SUBSTRATE WITH VULKEM 116 ADHESIVE CAULK OR
<br />APPROVED EQUAL APPUCATION OF V1JLKEM 115 ADHESIVE CAULK OR APPROVED
<br />EQUAL AT FRAME SILL MUST COi'lPl Y WITH SEAlANT MANUFAcnJRER'S
<br />RECOMMENDA:JONS.
<br />-1-\ 3) USE SILICONIZED ACRYUC CAULK FOR PERiMETER SEAL AROUND EXTERiOR OF
<br />ill WINDOW FW\NGE AND TO SEAL HEADS OF INSTALLATION FASTENERS,
<br />4) FLORIDA EXTRUDERS 1000 SERIES SINGLE H\';NG IS SHOWN. THIS PRINT ALSO
<br />APPUES TO THE FLORIDA EXTRUDERS 1500 A.ND ;>.000 SERIES SINGLE ~UNGS.
<br />5) WINDOW FRAME i'iATERIAl: ALUMINUt~ ALLOY 6C63.
<br />
<br />'7
<br />
<br />:::i_ASS
<br />\ TYP )($(( ~C""ES>
<br />
<br />"
<br />
<br />ANCHOR INSTALLATION INSTRUCTIONS
<br />
<br />GENERAL:
<br />
<br />\
<br />
<br />"
<br />
<br />CQNCRE1'E OR
<br />~1ASONRY OP'ENl~G
<br />BY OTHERS
<br />
<br />6) NAIL AT7ACHI~ENT OF NON-STRUCTURAL ONE BY BUCK IS 4' FROM EACH CORNER
<br />& AND B" ON CENTER. USE A HARDENED "T.NAlL" WITH A 0.097" DIAMETER AND 1 3/8"
<br />LENGTH (5/8" EM8EDMENT), A HARDENED "MASONRY NAIL" 'NI-:1-I A 0.1~" DIAMETER
<br />AND 1 1/2" LENGTli (3/4" EMBEDMENT) OR EQUNALE,NT. FOR ALTERNATE SECTION
<br />A'Ala.6, USE A 0.113" DIAMETER COMMON WIRE NAlL WIc~ A 314" E'16EDME1'.T OR
<br />EQUIVALEi'lT FOR NAlUNG NON-s-:-RUCTJRAl ONE BY BUCK INTO A TWO BY
<br />STRUCTURAL BUCK.
<br />& 7) APPlJES TO ALL NON-STRUCTURAL BUCKS LESS THAN I 1/2" -HICKNESS. NOT
<br />INTCNDED TO LIMIT TO NOMINAL ONE BY WOOD BUCK ONLY. BUCKS GREATER THA.N
<br />1" NOMW.AL (3/4" THICK) AND LESS THAN 2" NOMINAL (1 1/2" TH!CK) W!LL REQUIRE
<br />.6 NAILLENGTli SUFFICIENT TO 'lEFT EMBEDMENl' REQUIREMENTS OF NOTE 6.
<br />ill B) ALL INSTALLATION ANCHORS MUST BE MADE OF CORROSION RESlSTA\'T
<br />MATERIALS OR HAVE A CORROSION RESIST ANT COATING APPl.1ED SUITAf3lE FOR THE
<br />ENYlRONMEi'lT AND/OR FRA.'IING MATERlAL. WHERE ANCHORS ARE JSED IN
<br />PRESSURE-PRESERVATIVE TREATED WOOD, THE WOOD SUPPUER SHALL BE
<br />CONSULTED FOR RECOMMENDATION OF ANCHORS COt~PA11BlE Wrr~ THE
<br />PRESSURE-PRESERVI\rrvE TREATMENT PROCESS USED.
<br />9) ALL FIELD SUPPUED HOIJ'S IN THE FRAME (IF ,REQUIRED) WIll6E 3/16' IN
<br />DIAMETER.
<br />10) WOOD SCREWS SHALL MEET ANSI B1S,51 DIMENSIONAL REQUIREMENTS.
<br />11) IF WOOl? TENDS TO SPlIT, PRE.BORE HOLES AS FOLLOWS: #8 WOOD SCREW.
<br />l/S" DIA. PILOT HOLE &. ttlO WOOD SCREW. 9/64" DlA. PI~OT HOLE (NATIONAL
<br />DESIGN SPEOFlCATION FOR WDOD CONSTRUCTION).
<br />[SEE SHEET 2 FOR CONTlNlJATJO'N OF NOTES]
<br />
<br />I
<br />1-3/8' I -.......,
<br />~IN. EME ~
<br />~?
<br />ILJl
<br />IW
<br />
<br />:::~
<br />;{. "'- 2X4, 2X5, 2XS IIOGD BUCK
<br />______ BY OTMERS (SEE NO'E l6 ~ 23) ~
<br />....... JI GNe: BY 101000 BUCK BY 07HERS
<br />~ ' (JP11ONAU (NOTE 5, 7 ond lSA)
<br />I~STAllAT!ON ANCHOR
<br />#10 \lDOD SCREIoI (NOTE i5 Qnd l5A)
<br />
<br />SECTIO:\! A-A (ALTERI\JATF!
<br />& For insto:lation with two by
<br />with or 1'1/0 one by wood bUCKS.
<br />
<br />. ''''. " ", '.. ......
<br />_.,..,< '~#<'~J~::.,:
<br />
<br />, :~~~~~:t~:~~~~\..: REVj DESCRIPTION !DATE IINI
<br />
<br />t,Y,),./ ", .:. ~ c IR'Y;SEO.NOTOS 3,6,7. :12/19/031" 'A
<br />'- ~f-- 1 B, ,6, SA.& 22. ADO€O I j:"'\:-..i
<br />'l. , . -/2:i/'3 . I ~~00~ A;g:;E~E:J\ITO i 'I
<br />I REFER\S"KE$ A,~D I
<br />
<br />II \~~~'f · i='- ~ '" I i
<br />
<br />WJ~
<br />~~
<br />
<br />FLORIDA EXTRUDERSI~1~~:-lY~~iVf'~~
<br />CEKTIACATE OF AV~"CR'ZAT 0' NO '2:35 SA...'iFORD FLORIDA
<br />TITLE: INS'AU_A T ION DETAIL
<br />S~L HJNS FLANGE ~INJO~S - SERIES ~DOO 1500 ~ 20JC
<br />DRAWN 'BY: BB APPROVED sY:R...-A
<br />l)ATE:12/19/03/sCALE:NTS,l)WG:>LEXiJC15,SHr 1 JF 2
<br />
<br />~~
<br />~~
<br />i~
<br />,~
<br />
<br />SINGLE HUNG
<br />
<br />FRAME (FIN)
<br />
<br />I r-- ~j~ '~~~CE
<br />
<br />I TwO BY wOJD
<br />
<br />I / /\iBY ~,HERS ;
<br />~~1/}11
<br />L J~ j>LI\
<br />W[~iJJ,'JNF;~~~~' J ;11., \- ~~~~~~~}i:~:S
<br />
<br />'AMB ' I
<br />~ PERIME' E R I"IS' AL L A Tl ON ANCHOR
<br />CAULK #8 \l00r; $C.'<E\I SYO\l~
<br />BY iJT.~ERS STJCCO BY eTHERS
<br />SECTiON B-B
<br />
<br />CAULK BETIoIEEN
<br />wl~D~w FiN !or
<br />S~EA-rllNG
<br />
<br />-l 1-- l' "i~ L~BEDME\-
<br />('w'Don seRE N)
<br />
<br />r:TW~ BY \1000
<br />BY OTHERS
<br />
<br />i SHIM ~s CE~ D
<br />I / ' (SEE NC-':S)
<br />
<br />SL<€A ;'r-GNG
<br />BY O'-HERS
<br />
<br />\lI,~DC".'
<br />:1E.IGHi
<br />
<br />GL~ZING CTY?) I
<br />(SEE NO-ES) ____________...1
<br />
<br />I
<br />
<br />PERIMnER
<br />CAULK
<br />3Y DTrlERS
<br />
<br />SECTiON A-A
<br />
<br />i---- I'MI'i,
<br />EMBED,i'iENT
<br />(1,,'000 SC~Ew)
<br />
<br />- wl~DC'.' '.'IIHH
<br />
<br />IMPORTANT INFORMATION &. GENERAL NOTES
<br />
<br />These notes are pro\o1ded to ensure proper instal!aoon of fiorida Extn,..ders Mdestore
<br />products and must be followed fully.
<br />
<br />SHi~ AS REQ'D,
<br />(SEE 'iClTES)
<br />
<br />GENERAL INST ALLA TION INSTRUcnCNS
<br />
<br />1) SHIM M; REQ'D. AT EA01lNSTAUATION ANOiOR Wl~H LOAD BEARJNG SHIM.
<br />:-'lAX. ALl01NABLE SHIM $TACK TO BE 1;4". APPLY A BEAD OF VVlKEM 116
<br />ADHESIVE CAuLK OR APPROVED EQUAL AT THE FASTENER "OCATION PRlCR TO
<br />INSERTING THE SHIM TO ADHERE THE SHIM TO THE SGBSTRATE A.~DIOR
<br />WINDOW FRAME. FULL BEARi~G BFTWEEN THE SHIM. SGBSTRATE A~D WINOOW
<br />FRAME ARE REQU;RED.
<br />2) USE SIUCONIZED ACRYLiC CAuLK BEHIND \VI,~OOW FIN AT HEAD, SILl &,
<br />JAMBS,
<br />3) USE SIUCONIZED ACRYUC CAULK FOR PERlMETER SEAl. AROUND oxrrRlOR. OF
<br />WINOOW FRAME.
<br />4) FLORIDA EXTRUDERS 1000 SERIES SINGLE HUNG IS SHOWN. THIS PRINT ~LSO
<br />APPUES TO THE FLORlDA EX1RUDERS 1500 AND 2000 SERiES SiNGLE HUNGS,
<br />5) WINDOW FRAME IoIATERlAL' ALUMINUM ALLOY 5063.
<br />
<br />ANCHCR INSTAlJ.ATION INSTRUCT10NS
<br />
<br />l' M:N.
<br />EMBEDMENT
<br />(VOOI:l SeRE'w')
<br />
<br />5HEATH1NG
<br />
<br />r' - '.:NDOW' --i
<br />wIDTH ;
<br />I Ai:
<br />
<br />hi 0 0 1 ~ !
<br />, ii' /'r I
<br />-L....-I!I a: B :
<br />A.'iCHCR ~: ,
<br />SPACING III (QUI'LL Y SPACE
<br />(SEE BELQ\I)II i 'I ~~CHCRS (TvP) Dr
<br />...---- M ! I ' LQ:"
<br />.I~no.. T Iii / ':1 i
<br />HEIGHT ~Iil ",.1 !
<br />I · I. 1
<br />
<br />ANCHCR ! I A 'i 6' "AX -1
<br />SPACING:-i r II (TYPJ
<br />(SEE BELOV) ...J,-- $' MAX. (TYP.)
<br />~LEVATION
<br />
<br />GENERAL:
<br />
<br />&
<br />
<br />6) ALL INSTALLATION ANCHORS ,"UST BE IoIADE Df CORROSION RESiSTANT
<br />,'1ATERlALS OR HAVE A CORROSlON RESISTANT COATING ~PPUED SUITABLE FOR
<br />THE ENVIRONMENT AND/OR FRA,'lING .'1ATERlAL. WHERE ANCHORS AR.E USED IN
<br />PRESSURE.PRESERVATIVE TREATED WOOD, THE WOOD SUPPUER SHALL BE
<br />CONSULTED FOR RECOMMENDATION OF ANOiORS COMPATIBLE WITH c-1E
<br />PRESSURE-PRESERVATIVE TREATMENT PROCESS USED.
<br />7) All FIELD SUPPUED HOLES IN THE FRAME (IF REQUIRED) WILL BE:
<br />a) 3116" IN DIAMETER FOR #B WOOO SCREWS. AND
<br />0) mE SHANK DlAMETIR. OF THE NAll ROUNDED UP TO THE NEXT ST~NOARD
<br />DESIGNATION DRILL BIT SIZE,
<br />8) WOOD SCREWS SHALL MEET ANSI 618 6.1 DiMENSIONAL REQUiREMENTS.
<br />9) NAlLS SHALL MEET ASTM F 1667, "STANDARD SPECIFKATlON FOR DRIVEN
<br />FASTENERS: NAlLS, SPIKES, A,~D STAPLES."
<br />10) IF WOOD TENDS TO SPLIT, PRE-IlORE HOLE M; FOLLOWS (PER NA'10NAL
<br />DESIGN SPECIFICATION FOR. WOOD CONSTRUC11CN REQIJIRE~lENTS::
<br />a) #8 WOOD SCREWS, l/B" DlA. PILOT HOLE,
<br />b) 0.113" DIA. NAlLS - #44 DRJLl SIZE PILOT HOLE.
<br />0) OTHER NAIL DlAMETER PILOT HOLES NOT EXCEEDING 75% OF -:HE NAIL'S
<br />DlA~1ETER M; REQUIRED.
<br />11) WOOD SCREW AND NAll W1THDRAWAL VALUES USE) TO GENERA-E
<br />FASTENING REQUIREMENTS ARE BASED ON SOUTHERN PINE WITH A SPECIFIC
<br />GRAVITY Of 0.55.
<br />12) WOOD SCREWS AND ~AlLS SHA:.J. NOT BE MIXED TO FASTEN ~c1E SAME
<br />ASSEMBLY. -
<br />13) WOOD SCREWS AND NAILS SHAH. NOT BE USED TO FASTEN ASSEV,BLY jNTO
<br />THE END GRAIN Of WOOD. -
<br />
<br />[SEE SHEET 2 FOR CONTINuA TIDN OF NOTI'S]
<br />
<br />VIEWED FROM EX"ERIOR
<br />H;::AD SI' L !. .JAMB ANCHOR SPACING rT~ 70 PS, D P,)
<br />
<br />'.'DOD SCRE''', 24' O,C ~AX <TYP)
<br />
<br />\~.11_, 7' 0 C. MAX FOR .JA,~BS A:'iD
<br />10' D.C, ~,AX FOR ~EA~ ~ SILL
<br />
<br />~
<br />~~
<br />
<br />[i1j'~"~~ ,
<br />..t~~,t~/r
<br />
<br />1 Of' 2
<br />
<br />REVI DESCRIPTION DATE !NI
<br />~66'S~~QJ~~;uTO lD/l/03 RJA
<br />i A~\~~HEt6c~TI~~LK
<br />c I~~:~~g ~g~ ~',>ND il2110/D3 RJA
<br />I TITLE TO REFlEcr NAil I i
<br />IALTERNAT( ,
<br />i i I
<br />
<br />5:" d
<br />~~
<br />~~
<br />.U
<br />':J
<br />
<br />FLORIDA EXTRUDERS 11~~~NSl~Vr\l:~~
<br />CEKT1~CA11: 0' AUT\;ORIZA"ON 'D. 9205 SA..\iFORD FLORIDA
<br />TITLE: INSTALLATiON DETAILw/#8 SCRE'.S CR I,~ILS
<br />SINGLE YJNG FIN \lINDo~ - SERIES 1000,15:;0,
<br />DRAWN BY: BE ! APPROVED SY. RA
<br />DATE: 12/10103 : SCALE: 'i T, S, IDWG.:FLEX0026 S~T
<br />
<br />I;;w
<br />~~
<br />:;!'"
<br />
<br />!. 2000
<br />
<br />~Cl) Sri --.., nt x 2 X ./8 !Coo SH -, r1 x 2 X 31B
<br />_A'3 "YO)l, r-', ;:"lUIDN _AM! (TYP),I\ ~~KUlLJON
<br />
<br />
<br />
<br />~ ,i ..,..r itS x 1/2 SELF MJ ........ 119 x 1/2. SELF
<br />~ TAPPING SM$ r APPI"iG s,~s
<br />
<br />11 1,Ii JU 'II Ii
<br />
<br />-'
<br />
<br />-ryP1CAl \fERriCA.... TO HCR;ZONTAl V0LLJON 70 Mv:..L;ON
<br />,
<br />
<br />-----.:.c,;
<br />s~~ ~~': ~~~a~~ .J/
<br />!. ~UlLICN
<br />
<br />\ I'
<br />\ <JJ ---..\<?
<br />~ SEALANT 8P"'i:E:N r /
<br />'KiNDQY FLIlNGES -v
<br />S. '1L:LUON
<br />ij6 X j-~/2: $(I_F
<br />T APPJNG $.MS
<br />A-A, ( 1) SECTION A, A
<br />
<br />(2\
<br />
<br />II
<br />;:>)
<br />
<br />\,- #9 x 1-1/2: SELF
<br />~ AP?!NG $J.i$
<br />
<br />SECT'O'i
<br />
<br />~1 X e 7/16 )( I/a
<br />L'3E ~UlLlOt-j ;- 1 X a 7/~6 x 3/9
<br />" JC $ H...., r- ~coo SJi,""""""'1 ,,-L, Tl.!'3E HULL10N
<br />~A,Y\3 ',"Y?)~ 1 1 .,JA,MB (":'Y? > \1 : ~ I
<br />
<br />
<br />,I ~ ,. x "2 $(LF ~i, ~ '8 X 1/2 SElP
<br />'-APPING SMS fa ~APprNG SIolS
<br />y==ly ~ JI '! 1
<br />
<br />--'
<br />St~~~8: ~i~~~~~ -.V
<br />& ~UlL1CN
<br />
<br />((
<br /><l! . ....\"
<br />\ St1~~~~ ~i~~6~~ ....v
<br />\ " fl:1)L LIeN
<br />"-Ita x l-l/Z SELF
<br />A-A (3,',"P1NG SMS
<br />
<br />";;JI
<br />\--. #8 X 1-1/2 SELF
<br />TAPPING S/'4S
<br />
<br />SECTION
<br />
<br />SECTION A-A (4.)
<br />
<br />." H ill !!/'~\~"'\
<br />
<br />
<br />CA,'! cryP) II i I
<br />
<br />~ I ~ 'S x :/2 SEeP
<br />~ " :] ------ 'l'APP:NG SM$
<br />~ ~
<br />
<br />ir-,!
<br />1000 SH.'; I
<br />JAM]! CTY?) I,
<br />\ I
<br />~I I
<br />~ I r.#B X l/2 StLF
<br />:- A?pr~G SMS
<br />
<br />1 X 4 X 3/B
<br />T',,3E ~ULL10N
<br />
<br />I _n
<br />w _'"
<br />IQ.:r--.::;~
<br />!~.N,..,Lf":
<br />!~i::~
<br />/14: CD -i ~
<br />v~.28
<br />'S,.lf"'> E~
<br />I~ O...J
<br />Ik
<br />
<br />HORIZONTAL SLIDER
<br />
<br />MASONRY (FLANGE)
<br />
<br />TYPICAL MULL INSTALLATION
<br />
<br />~ \ ~ ~9: X 1-112 SELF~
<br />\ '"'- r ~EALANT BE.T\tEEN TAPP!NG $MS
<br />"--- ''J:tdlCW' F'LANOES
<br />to I'Ut..l...lCN
<br />"'- ~8 ;( 1-j/2 SELF
<br />~ APP!NG SMS
<br />SECTION A-A (4)
<br />rlX4X3/6
<br />~ TUBE I'IL.t.LION
<br />
<br />ir=n'
<br />I I
<br />
<br />JA"~O~T:P~ ~\ : I !
<br />
<br />
<br />
<br />'S x lie SELF ~ll ! ~ 'S X 1/2 SELF
<br />r AP?!NG SMS W,tL "Jl___ rAPPING SMS
<br />
<br />~liJ~
<br />
<br />3..
<br />
<br />.- lOCO P V IDESIGNER r- DCO P 'w'.JDESIGNE:R
<br />
<br />
<br />~;I "; "" ',,/ Sll;,,':"x 3/4 SElf"
<br />";" ~PPING $NS !l / ~ APPING $MS
<br />
<br />r- II" III
<br />4L::JJr~u~~~J~~;J~~~gN ; ~ ;o~E2~L~~N
<br />
<br />
<br />
<br />SEAL"" 'C-'.i€EN~ ~.S X 3/4 SElP ~, J I ~B X 3/4 SElf'
<br />IJINDCV r:"ANGES \... \ TAPPI"G SMS
<br />.. Io1L!LLlCN ~ WOO S.H ,APP!NG SMS "--- L000 S.H ,..., ~ 1000 Pol /DES!GNER
<br />S[JllANT lltTW'(r1AD (TYP> ....1 r~ ;~~~I~;;.) A-A (2) SIL... <TY?)
<br />\~I~Be:*,~LANGES SECI ON A~A l I) rtl8 x 3/4 SELF
<br />~. r JOOO P,\I./DESIGN(R r ~ar~O ~;....~~SlGNt~ / 1AP?!NG s'MS 2 X 4 X 3ig
<br />I SILL <T'(?,) '- r Tlia:( MULUON
<br />r~e x 3/4 SELF r~8 x 3/4 SELF II ~"II
<br />\ ~ / r"PP!N'Ci S~S L ~ 2 7/16 ;( ,/8 / ~APPING ~rMS 1;( 2 71i6 X 3/8
<br />'\ lor;- " /r ',,'E MlU1CN W.II u, II TU'E _ULUON 11.
<br />\ 11'111 !I ,_.11 SEALANT ,m'<E._ \-/0
<br />\ ~ J I ~l~tE~ID~lANGe:
<br />\ / r '. II StALANT '''''trN /" L .
<br />~.. . I: I ....:NDOY "LAN'G[S-L..., _....
<br />J I II · <ULLlON I JI I
<br />
<br />
<br />I ~#8 X 3/4 Sf:.LP'
<br />'--- LOOO S H. T APPIN(j SMS
<br />f-<EAD (TYP'.)
<br />
<br />SECTiON A-A (4)
<br />
<br />CD~C~ETE OR~AULK BETwEEN '.OOD LNS'AllAllON ANCHJR IMPORTANT INFORMATION llt GENERAL NOTES
<br />I::c. ',ASONRY OPl~:NG BXK ~ "AS'Y ;Z=PE~;NG 3/'6' "iA TAPPER
<br />LD 3Y O"1"HERS BY JTHERS: CNCTE ~2) These notes are prov\deC ~D enS..Jre proper 10s1;allator; of Florea Extn.,ders M.iestore
<br />IJNE BY ',...'DoD _ ~ products and must t.e fa lov1ed ful'y
<br />BUCK BY JrHe:RS~ I I
<br />CNCTE 5 ~ 7) <:\ e::. I, ~~I{i~M~~N.. GEI.ERAJ.INSTAL:.ATlON ,NSTRUCTlONS 7) APPLIES TO ALL 'JON-STRIJCTURAL BUCKS LESS rHAN 11/2" T"HICJ<NESS. ~JOT
<br />CAU-K Bn.. C, " - ,,- INTENDED ro LIMlT TO NOMINAL ONE BY WOOD BUCK ONLY. BUCKS GREATER
<br />'''I~DS';06L~~g~ 1) SH1M AS RE'<,D AT EACTH INSTA":-"'ION ANCHOR Wffi1 LOAD BEARING SH1M. ~AX. Dr THAN 1" NOMIMAL (3/4" THICK) A~D LESS THAN 2" NOMINAL (11/2" THICK) WE.l
<br />- ~ I> v=-- I A,LQWABLE SH,M STACK 0 BE 1,4 . LQ:" REQUIRE NAIL LENG1'H SUFFIOENT TO MEET EM6e~MENT REQUIREMEN"T';; OF
<br />. \ :,.j 1/4' SHI." 2) USE SIUCONIZED ACRYUC CAULK BEHIND WINDCW FLANGE AT HEAD &, JAMIlS, SU NOTE 6
<br />,~ c-... SPACE ~~X -I ~UST BE A;ACHED T~ TH~ SvBSTRATE WlTH VULK.E," lIS ADHESIVE CAULK OR B) A~L lNST4LLATION ANCHORS MUST BE f<'ADE Of CORROSION RESISTANT
<br />II -.... . APPROVED _QUAL. AFPClCA, ION DF VUlKEM liE ,WESlVE CAULK AT FAA~E 51U. ,"CST MATORlALS OR "AVE A CORROSIDN RESISTANT COATING APPUED SUlTABlE ,'{)R
<br />II I COM~lY \lVI":"'rl SEALANT MANUFACi'uRER'S RECOM!'-1E'IOATIONS n"'H~ ENVIRONMENT AND/OR FRAMING MATERIAL VVKERE ANCHORS ARE '..;SEO IN
<br />I II I!l ,6,c 3/ uSE srUCO~1lEO ACRYLIC CAULK FOR. PERlM8"ER SEAL AROliNO EXlE.PJO~ Of PRESSURE-PRESERVATl'Yf TREATED WOOD THE WOOD SUPPUER SHALL Be
<br />"y ~TT~S~~ _ II II'f I'I Lh..::, WINDOW FLANGE AND TO SEAL HEADS OF INSTALLATION FAS-:~ERS. CONSUL TED FOR RECOMMENDATION OF ANCHORS COMPATIBLE WITH THE
<br />D -" c~" I ~J ') FLDRlOA EXTRUDERS 1000 SERJES HORJZONTAL SUDER IS SHOW~ PRESSURE. PRESERVATIVE TREATMEm PROCESS JSED.
<br />iI"-L- S) NINDOW FRAME MATERIAL AeUI~INUM ALlOY 5<)63 9) ALL FIELD SUPPUED HOL.ES IN THE FRA;1E (IF REQUIRED) WH BE 3116" IN
<br />II ec",",-" 'NlFDII SHi~ AS ,EQ;) DIAMETER.
<br />- CAULK I II (SEE ~OT::S) B H '"CHaR INSTAdATION ,~STRUcnONS 10) WOOD SCREWS SHALL i-'EET ANSI BIB 6.1 DI"ENSIONAL REQUIREMENTS
<br />BY OTHERS I ,I (BUCK 11) IF WOOD TENDS TO SPLlT. PRE.IlORE HOLES M; FOLLOWS, #8 WOOD
<br />w ~ i5 ' I HE!GHT) GENERAL: SCREW - 118" DIA. PILOT HOLE & #10 WOOD SCREW, 9(64" DIA. PILOT HOlE
<br />':,!~;,~ /, S G\::gc. ,;,.,c I ~ ;!. :~~;~H~~;~TA O:A~~~~~;U~~:'~ ~ ce~;~ ~~:,~~~ ~;~ ~~S~~~~;~ (NATIONAL DESIGN SPECiFICAnON FOR WOOO CQNSTRUC110r..)
<br />
<br />I GLASS cryP) -.-l ~ ~(ADER ,,- 5/S" EMSEDMENT), A HA'DENED MASONR.Y MIL' WT'"H A 0148" DIAMETER <ND) ',,' 3/16" DlA. TAPPER CONCRETE SCREW (WITH NON.STRUCTURAL ONE BY
<br />(SEE NO-(5) ~ ~ , i LEN.,,-H .3(4' EMSEO~lcNT) OR EQVrvAcENT wooo BUCK):
<br />I I II " 1-\ ON[ BY 101000 KiCK 8Y C:;NCRE-E JR
<br />, ,I \ I ~ DT:-<ERS ,"leTS S &. 7) \ o,;.:.SONI;C:Y O?E~HNG 12) WHERE WINOOW is INSTALLED IN MASONRY OPE,'HNG I.YrTH 4,
<br />I "1'1 B ',; \ BY O-~ERS NON-S"TRUCTURAL ONE BY WOOD BUCK (NOTE 7), cJse A 3116" DlA. TAPPER
<br />I I \ - CONCRETE SCREW Of SUFFIOENT L"rn TO ACHIEVE MIN EMBEDMENT OF 1-1/4"
<br />I !i 'L--1l' L R:G:D VINY_ ! (BUCK "'!~~~)1I4' SHH~_J\ .i~~:~~;M~~~r INTO MASONRY OR CONCRFif,
<br />p'Kr"'1t:T~R i I ~ GLAZhG BE~Dr FLANGE TYPE SPACE MAX ,f\ I 13) SEE SHEET 2.FOR 'rAPPER rNsr-AlLA.TfON ANCHCR. LOCATION CHART L.ETTER
<br />- rAULK I! (TYP) 1 'w'[NDO\/ FRA.V,E $HZI-i AS R€:'Q'D \' i \ I DESIGNATIONS ON THE TAPPER LOCATION CHART INDICATE WHERE TA?PER
<br />IBY JT~ERS ---\ il I FLANGE TYPCJ .A."B ~S[E-'~CTES)'~' : > CONCRm SCREWS ARE TO BE;NSTAu.EDWHEN '.,SINGTHEEX"ERJOR
<br />I 1\11'1 ~~[ILNLD'JV FRA,"€ iNSi3A/~,~~T~?,," e'ANCpHp9~~ "-... 1,,1, ELEVATION ASAKEY.
<br />, 0 "" c, '" :<) TAPPER (RAWl) CONCRETE SCREW MANUFACTURED SY POWERS fASTENING,
<br />I (~OrE 12) 'It 'X V" , I~C. WILL BE USEO. TAPCON (by aco TEXTRON I~C.J OR mEN (by SIMFSON
<br />, ' RiGiD VINYL 1\ 1 STRONG. TIE) CAN BE SU8SmVTED WITH THE FOLLOWING UMTTATJONS FOR
<br />r -",' '" \ (1 ~LAZI~G BEA~ ~1 T"HE HORlZONTAL SUDING WINDOW SlZE 024,0245, D2S AND D26:
<br />3li4' ~lASS (TYO) /' Ii I'l' a) INSTALL n~o ADDfTlOML FASTENERS IN HEAD OVER CHART
<br />------: / (SEE NO-ES)', ) / REQUI~EMENTS AT LOCATIONS A AND O.
<br />,,~, ,m,,," / -/' ~ \ I {( i,l ily I / \ 0 15) ALL REMAlNiNG FACTORY APPUED INSTALLA~[ON FASTENER HOLES NOT
<br />.'INDOw FI_ANG€ /"'1 _ II I" I USED FOR TAPPER CONCRm SCREW INSTALLATION SHOULD BE FILLED Wffi1 #8
<br />!or PRE CAS T SILL ~ I I' ~ .1 'I'. WOOD SCREWS Of SUf'FlCIENT L TH. TO PROVIDE MIN. 5/B IN EM8EDMEN1 INTO
<br />wIVULK[~ 116 i Sr::CT'ON A A ___ ~~~I 1'1000 BUCK.
<br />ADHES;VE CAULK PRECAST SILL --J ._" - C4ULK Bn,"E~E~ ___ __,\
<br />OR AP?ROVED EQL BY O"HERS '.;NDO\,! rLANGE I #10 WOOD SCREW (WITH STRUCTURAL lWO BY WOOD BUCK):
<br />'1 \ ,"'DOil BU:K p
<br />r- \..'tI. ~
<br />^ PERI~E'ER 16) WHERE WINDOW [S INSTALLED IN '1A50NRY OPENING WlTH 1\ STRUCT1..:RAl
<br />I /-" -I I C~JI K STUCCO ,1 j n~o BY WOOD BUCK, USE #10 WOOD SCREWS (A,~SI818.61) OF SUFF!ClENT
<br />. A 8 C I D I BY OTHERS BY C'HERS 'J LENGTH TO ACHIEVE 1.)/8" MIN. EMBEDMENT INTO THe TWO BY WOOD BUCK.
<br />.' w r" LK BO" '>EN 17) #10 WOOD SCREWS ShAll BE INSTAllED AT AeL FACTORY APPUED
<br />
<br />\}'I,'H GEn nil, 1.$ i;# rt F "i+""~,,,,-;M,";W"'-SF~C ~~;;i:1t\<,\; l[*'E=[,~i:~=;~:;;:"",f~:;:g.':;::;~
<br />/:/ r A q! :"~",",,'\4~f~:"~'" REVI DESCRIPTION DATE lKI FLORIDA EXTRUDERS 111~:yi~1'f\...t~i
<br />BIB i~ /(\J l!" ~;. ~"i-...+-:-:-, B !~O;R~~T~~0-Y~~A,~'Go;51'CI16/03IR_A CERTrf!CA'E or AUTf'OR'ZA"O' "'D. 9235 SM,'FORD, FLORlDA
<br />I 'I ~ii j"';', \ .N'1.,2' ''"'' ,COCA110N ON ANC"ORSI I 'I'l~~. INSTAl LATION DEIAIl 'II 'APPFRS
<br />Ltt I r+J ,'5 :,"Y' ~"""...:,: _: ,ON 2, 3, 20 'NO 30 ,w;. '- - " - -
<br />
<br />E LEV A TI 0 NA. ---.J g "::i:~'1<':l!ff~t:~",..,:!;" c I~~:r:~~\ 'to~dg ::2/19/D3 R...-A D~;;ByS;BI DING FLANG~:'q~;;~Y-R.JSAER I ES 1000
<br />
<br />V,EWED FROM EXTERIOR"'.,.':'.::'.' lONE BY aueK CAcC-OcT. i DATE' 12/19/03'SCALE: NTS DWG: FLEX0020 SHEET 1 OF 2
<br />
<br />ANCHOR INS1AcLATION INSTRUCTIONS (CONT)
<br />
<br />WOOSH-, lx2Xl/8 'DOOSH.l r~x:=X:3/8
<br />""AM! (~'(P) \ TUBe MULl...roN JAMS CY?,) \ rL '"<-BE l"ULLlGN
<br />
<br />
<br />
<br />~ h" ~ _ 'B X )/2 SELr 1 L'J r- os x 1/2 SEL<
<br />r ,I:lI ..,/' TAPPING $MS d TAPP!NG SMS
<br />
<br />~' J~ ' -'iL,
<br />
<br />CNE BY "ODD 0 CONCRS-E JR CAulK BOIolEEN
<br />BUCK BY O-HERS~&.:l. ~ASJNRY OPEN'7ING '.000 BUCK &
<br />(NO-E 6 ~ 7) BY OTHERS ~AS'Y OPENING
<br />BY OT"ERS
<br />CAULK BETIIEEN
<br />wiNDO.. rLANG~ ~ I
<br />~ wOO;) BUCK . :-;/4' ~IN
<br />c:. 4. EiABEDMPH
<br />
<br />~S." k I
<br />I r' .--1@ /!'-... .~ I'NSTAL'_ATlON ANCHCR
<br />/ L~ 31l6' DIA, TAPPER (NOT[ :.::'l
<br />STUCCO ...J ~ \~ : i
<br />'BY eTHERS ~ SHi" AS REQ'~'I
<br />C7 1/4' MAX.
<br />PE~I2~~E~ (S(E NOTES)
<br />BY OTHERS ! \
<br />
<br />i /1' \.- FLANGE -YPE I
<br />I \i[NDCV '""RAME I
<br />R!GiD VINYL I 'lEADER
<br />GLAZING BEAD I
<br />'';.H. <TY?.) l ~LASS
<br />(,,'iN~O'" ~ ~ CTY?) (SEE NO,ES) I
<br />HE~T) '~ M
<br />I h' (BUCK
<br />CAULK BO'''EEN '..INDO'" HEIGHT>
<br />rLANGE ~ PRECAsr SILL
<br />VI VULKEi'1 116 ADHESIVEl
<br />CAULK, DR A.PRV D EQl IH'
<br />F"LANGf: TYPS
<br />, _RIME E, 1M! ~ wI,DO,,", PRAME
<br />I :: Q~~~~~ \ t ~l'/ SILL
<br />I @ . \~
<br />PRECAST SIll ~ D. I
<br />BY O""HE:RS 'Q ~
<br />SECTiON A-A
<br />i-\";,\.I.-~
<br />)' A ~ I' VEWED FROM
<br />A 81 C EXTERiOR
<br />to iT /. +E
<br />I I f/' I,
<br />I J + B K 8
<br />
<br />Vl i
<br />
<br />I~STAlLATICJ~ ANc'-1CR
<br />~8 wOOD SCR(.' SHO'.N _______--------+-:_
<br />
<br />STof'CO E !
<br />BY a-HERS . ! /'\ i I
<br />\j _ GL...AZING (TVp.)
<br />7 =-,; J (SEE NOTES)
<br />PER:METER ' II ~/ 4' MAX,
<br />C~ULK Ir ~'"(" SPACE
<br />BY O"HE~S 1 L-.
<br />
<br />I Ui~D~::ErRP'::
<br />I HEA De:R
<br />GlAZ1'JG (TV?)
<br />1 ~ (SEE NarES)
<br />:I../'
<br />
<br />~
<br />
<br />f-- FIN TYPE
<br />, V wlNDOV FRAME
<br />
<br />
<br />~.. ~L~i~~~:;'
<br />~~'I,)' ~
<br />T'.O BY "OO~
<br />L'iSTALlATElN ANCHOR .: I -------- - BY O-"ERS
<br />~6 'r./OOD SCRE" SHOVN " I I "--..
<br />
<br />"'."" .'
<br />STUCCO -------------./]1
<br />BY OTrlERS J
<br />
<br />CAULK B€1I1EE~
<br />'''iNDO''"' F]~ Sf-'EATHI~G
<br />~ SHEA rHlNG BY OTHERS __
<br />
<br />I
<br />
<br />2X4X3/9\! I
<br />TeSE 'UlLlQN \1-1 I :NS-'e'_AClCN ,c.~ ------: 1:
<br />
<br />I I II ...----INTER~~l C_IP
<br />JA{o1'~0~TYS?~ l 1 :' V
<br />, I '.
<br />J II [j. ,I
<br />~ I r::-- ~~ x :'2 STLF I fv--l+
<br />~ ~ .....,h.PPI'" SMS: ..J l- lX L:R 2X ~ULL (TYP)
<br />
<br />" I SECTION 3-8
<br />(C; 0'1, ~I) r[:!'IS:AlLATlON "''''CI-'CR
<br />SS~,~~~ ~I~~a~~ ,/' I II, I I 3/16' D:A, TAf>CCN
<br />ll. ML'LUON ~~f':r~G~';;~sSELF' r II f : I SCR("W' ANCI-<'CR ,"TyP)
<br />SECTION A-A (7, ' ----' I r >leL 'ClP
<br />___r-~\~ L J
<br />I ~ I I r lU4'~lN.
<br />'J 'c EMaE:tMi:N1
<br />
<br />ii' I ,"-All C ~ '\, I "- ":~~;L':~! '~<RS I
<br />
<br />'___:__~~__==-=--====== . I ~':":R il;DDrltlNpL AI'o:C1-'ORS, '"IHE:~ "E~l.,.:R(D'
<br />
<br />! 1)1# dill # II [0l 1,
<br />i L 'J]1"-, II I in;wj~__~j 1
<br />
<br />
<br />lil9 SElf 1 APf"JNG 3 ---...J tlULLlIJN:: ~"
<br />SMS(i"l'?) ~ i ~ I
<br />
<br />"E'/IED eROM EXTEil'OR ~
<br />
<br />GENERAL (CONT):
<br />
<br />'f.i
<br />
<br />_ .SL
<br />"t SEAl-ANT BE"'VUN
<br />'<--- Vl~DOY :'I..ANGES
<br />,. x l_~/~U's',J(~
<br />TAPPING s~s
<br />
<br />\J; "'"
<br />\. "r S(AI..ANr 5C"''"(0,
<br />"'L.- V1NlJO'w' f""-ANCCS
<br />\- ij9 X 1-1/~ "S~C~CN
<br />':"APP!NG s~s
<br />SECTION A-A ( 1 )
<br />l. x: 2 7/1& X l/8
<br />"ruB€: MULr...!CN
<br />
<br />SEC'-ION A-A (2)
<br />
<br />1000 S H.
<br />...10,'-1.3 (iyp)
<br />
<br />d 1 X ~ 7/16 X 3/9
<br />i:.;BE. foiut..UON
<br />
<br />I ,------,
<br />
<br />~
<br />...l ~ 118 X 1/2 SElF
<br />T APPING SMS
<br />
<br />lOOO S H. --, r::-
<br />",AI-l! n'iP) \ 1 r -;
<br />~I '
<br />~ ir
<br />
<br />146 x 1/2 SELr
<br />TAPPING SIo1$
<br />
<br />~
<br />
<br />'] fL==1
<br />
<br />~
<br />
<br />~
<br />
<br />'i
<br />
<br />!f;\
<br />~ ~ S("Ai..ANT lltT\.rt:t....
<br />'L ',,!jNDO.... r:"ANCE'S
<br />.. l'>.lJ1..L1CN
<br />~a x 1-l/2 SELF'
<br />iAPP:NG SM$
<br />_SECTION A-A (3)
<br />
<br />1 X 4 X 1/8
<br />T\..o'BE MULLlCN
<br />
<br />rr=
<br />
<br />i
<br />,
<br />!Coo s.M'l ; 1
<br />""AM) (T{P) I
<br />jl
<br />,
<br />
<br />,f::
<br />
<br />I
<br />'\
<br />
<br />~
<br />
<br />(c; \
<br />
<br />1?l
<br />
<br />\'" ,
<br />~, "f SEALAAT SENEEN
<br />'i- V:NDO'J f1,.,4NGES
<br />" MULL-ION
<br />#a x l-U2: SELf
<br />... A?P!NG s./oiS
<br />SECTION A-A (6)
<br />
<br />\ '\., S[ALANT ,!l[TlvED(
<br />\.- 'i...- 1J1NDC''.I FLANGeS
<br />\ KUlLIDN
<br />lie x ~-lJ"2 S'EL~
<br />T APP ING Sio1S
<br />
<br />SECTIO,N A A (5)
<br />
<br />\000 S.H. \ 1 X 2: X 3/8
<br />JA/olB (Tv?,) \ r..''B( MULLION
<br />~ ,.-------, ~ .. x l/2 SELF
<br />,.~Pf"rNG SMS
<br />~
<br />
<br />~oco SH.i
<br />A!'(3 (TV?) \
<br />,
<br />
<br />r I X 2 x 1/$,
<br />---/..-.-; TUBE: i-IUlLl:JN
<br />
<br />~
<br />~ ~:P~I~~2S~~Lf
<br />
<br />IJL
<br />
<br />~
<br />
<br />-
<br />I '!l
<br />---'~ :?l.
<br />\:.......... SOI...ANT lle:"'w'E~N
<br />"'------'-- "INDO\I' FRAME:
<br />Il. i"ULJ..lON
<br />1+3 X 1-1/2 Sf:.Lr
<br />-A,PP[~G SfoIS
<br />SECT,ON A-A (2)
<br />
<br />HORIZONTAL SLIDER
<br />
<br />,
<br />--.:.r;; \ <?l
<br />
<br />\\ ~ ~1~~~~'I' r~~1~~EN
<br />\ 10 MULL10N
<br />\-... jj9 x 1-1/2 SElr
<br />TAPPING SMS
<br />SECTIOt'-J A- A ( 1 )
<br />lX2i(16X~/e
<br />TUBE ~lilLlON
<br />
<br />1 X 2 7/16 )( 3/9
<br />7UB( MULLION
<br />
<br />FRAME (FIN)
<br />
<br />SHfA"";...j:\JG 'i~ T\JD BY ~OOD
<br />CAULK BET\oIEEN BY G-HERS 'I ~!I!iJ I( BY OT~ERS
<br />'>,"!iNDO'." FIN So
<br />S~EAT.1ING ~ III ~;~ '';\
<br />I~ST"LLATiO~ ANCHOR ~..,' II) \~~I
<br />#8 '''DOD SCREIoI SHQ..N ---~..r:' \
<br />S'UCCO OR I l
<br />SID1NG BY _____________ ; II'i,!1 / \ / \
<br />~T~ERS t- IjV
<br />
<br />~TER71 1r==='-"11 ~~
<br />C~ULK I [I
<br />BY ~-"r.RS I iliiJ' IJ
<br />Ii - , I~: SHI" AS REQ'O
<br />GLAZ;NG (TYP) ~ IrD (SEE NOTES)
<br />(SEE NC'ES) ~I W 1
<br />
<br />l' i
<br />: i
<br />I' i
<br />
<br />:CCO SH'l
<br />JAMB (Tv?) \ ~
<br />~ ~
<br />
<br />I
<br />
<br />1000 S~;' ~
<br />JAJ'.) CfY?)
<br />
<br />1t8 X ;/2 $(t.f
<br />... ~PPING SM$:
<br />
<br />[~ #S x 1/2 SELf"
<br />",PPING S"S
<br />
<br />'IDT -' ' 1/4' ~AX.
<br />~ '" .~DO'" w H - I SHIM SPACE CAULK BETwEEN
<br />TIIO BY '''ODD ~ ~ w[NDO'" FIN
<br />BY CTNERS ~ SHEAT~ING
<br />
<br />SHiM AS R::Q'~ ~ '
<br />(SEE NOTES) ~ .' I
<br />
<br />:. /\ 1//\ i
<br />rrl~' ~~!!/' \ 1 "_:~.IN.
<br />~I / ,i' 1 \ i. EMIrEJ)MENT
<br />I \V II' ~'''..''.':1CRE''')
<br />'~ rt=F
<br />
<br />
<br />I D't-; f; ,/
<br />I 1 I /
<br />
<br />GLAZING ClYP)J /lpER'METERJ / /1./
<br />(SEE NOTES) 'CAiJLK I ( SrlEA-HING
<br />J BY DT~ERS I; BY THERS
<br />FiN TYeE w'INDCW' S-UCCD JR J
<br />FR~ME .JAMB SlD~~2e:~~ q~s-::~~; TJg~E~'I~~~~N
<br />
<br />~
<br />
<br />!~
<br />
<br />If
<br />
<br />'--W'iNDLl'" \li:),!1 --I'
<br />! ::;
<br />J::;'..:lD i
<br />1 ~~~
<br />Uo:
<br />--11 ~ u.. w r'
<br />! 0~. A~ j
<br />
<br />r-i1 I1II I I -:'
<br />'"i'iDOV "II 4 I /.// ~ dUALLY
<br />HEiLF~HT ~: // 1./ ::~ A~~~g~S
<br />!II, :1 ',ii' (-ViP)
<br />~~o I 8 -o~ B
<br />AN:;~J, A ..-J II :::J
<br />L SPACI~G ;1 (TVP)
<br />(SEE BELJ..)
<br />6' MAX ny,::> > -.-;1"--
<br />
<br />'!l
<br />~t.; <,Jl
<br />
<br />\_ "" seALANT aE.n..~O:N
<br />__1- VINDIJ'i rRAME:
<br />&. MULLlDN
<br />- Ita x: ;-:Ie S[LF
<br />TM'P:NG SMS
<br />SFCTION A-A (3) SECTIO,N A-A (4)
<br />X4)(\lS rtX4;<3/S
<br />M~C!E flULLlO' I~ T~!E Ml!LLION
<br />
<br />II ; !"'--'I
<br />,I i I I
<br />
<br />!DOO S.H. I! ! : !COO SH..., i
<br />JM" (TIPJ i I ! 1 ~AM! (N) \
<br />
<br />
<br />~ r____ '8 x ,12 S(lF =i
<br />/" TAPP1"iG SI-iS
<br />~ J L--,
<br />
<br />\t; \ .--.--J <:'1
<br />
<br />\""'" SEAl-ANT anll'E.E:N
<br />'-- "INDO. '~AAE"
<br />"- "6 X l-U2. &.s;~lIaN
<br />TAPPING SMS
<br />SECTION A A (5)
<br />
<br />1/4' !>\AX
<br />I S~I~ 5?A:E
<br />
<br />\e; \"?L
<br />\:""'" I SEALANT BE:T\(,[EN
<br />'-------L...- '"I1NDCN' FRAto1E
<br />Il. )o\UlLlDN
<br />#8: X 1-1/2 S.ELF
<br />T AP?ING $~S
<br />
<br />FIN TYPE
<br />'''I~DOw FRAME
<br />~EADER
<br />
<br />i:M9 x 1/e SELf"
<br />T APP!NG SMS
<br />,~
<br />
<br />i i
<br />
<br />J
<br />
<br />i ! I
<br />,I Ii
<br />II a~1
<br />11 nE]~1 FI'l TYPE
<br />I'~ ,In /"' .~NDOW' F<A,~E
<br />r~ II t/ SIc,-
<br />I: 1 II
<br />.~ I: '~ ~"RBlE SiLL
<br />.. ~l LSTOOL BY
<br />I PERI~~~E~ ~I I O'HERs
<br />BY JTuERS I I'~ 1/4' SHl~
<br />I IW ~ ________~?ACE M,'X
<br />
<br />I~S"ALLATIC' ANCHCR I I 'is? \
<br />48 '''ODD SCRE'.' zSHO,,",N ~Il ""---- --:;:- AS REDD
<br />S'UCCJ JR l.- 'mr ;:> \ (SEE >lJ'ES)
<br />SlDd~~E~;-1 ,I ~ \ "......"
<br />, ~>I N ~~l,f.).tij~~,.,
<br />CAULK.. BEP..It;...EN I z~~ \ ~~ .. ~~ ,.- \~~ ' \J '
<br />,W,,~";,~ I:',';:i;; .~ 1ij'4r '000 ~ I: {Q<~~~~~~\".L"
<br />- OTHERS ~ ~ ; I. (t\t~~f1z.,t>
<br />S E C T 10 NA. - A j ~ ',' .f;~t~:~"~\":{;lr
<br />
<br />fi ct . '~(,~t~~h~. ~'.
<br />
<br />ELFVAT:ON
<br />
<br />((
<br />,e; \ ~L
<br />
<br />\ ~ StALANT lltT,*EEN
<br />'-- "'INDO\{ rRAMC
<br />\_ tl9 X t-1/2.'" S~U~lON
<br />,.. ~PPlNCi S~s.
<br />SECTION A-A (6}
<br />
<br />I,./I,\/DO\./
<br />....fIGHT
<br />
<br />';:E'IiEJ FROM EX'"i:R,()q
<br />HEAD SII' !or _ANB ANC~(;, S?~CI'iS
<br />
<br />IJOOD SC~E\,./, 2:4' C C, ~,AX. - T(] 70 PSF D P
<br />
<br />SECTION
<br />
<br />8-B
<br />
<br />NA:l 7' G C ,~AX, - 46 PSF -J 70 PSF D P
<br />>I"IL, ie' C C MAX. - '0 45 ?Sr D.P
<br />
<br />IMPORTANT INFORMATION llt GENERAL NOTES
<br />Tnese rotes a'e provided to ensure proper Installation of Florida Extruders Milestone products and must be
<br />followed fully.
<br />
<br />GENERAL INSTALLATION INSTRUCTIONS
<br />
<br />1) SHIM AS REQ'D. i\T EACH INS'7'ALIATION ANCHOR WITH LOAD BEARING SH1M. MAX. 4LOWABLE SHiM
<br />STACK TO Be 1/4". APPLY A BEAD OF VuLKEM 116 ADHeSIVE CAULK OR APPROVED EQl.AL AT THE
<br />FASTENER 'eOCAnO'i PRlOR 10 INSERTING THE SHIM TO ADHERE THE SHIM TO T~E SIJBSTRATE
<br />ANDIOR W:NDOW FRAME. RJLL BEARING BETWEEN THE SHIM, SUBSTRATE AND WINDOW FRAME ARE
<br />REQuIRED.
<br />2) USE SIUCONllED ACRYUC CAULK BEHIND WINDOW FIN AT HEAD, SILL & :A~1BS.
<br />3) USE SIUCONIZED ACRYUC CAULK FOR PERiMETER SEAL AROUND EXTERIOR Of Wl.~DOW FRAME.
<br />4) WINDOW FRAME ,"lATERIAL: ALUMINUM ALLOY 6063.
<br />
<br />[SEE SHEET 2 FOR CONTINUATION OF NOTES]
<br />
<br />REV] DESCRIPT;ON DATE I IN!
<br />2 i~~;s~~o~~~~~VOTO I 101: IC3 I R"; A
<br />lust: ,olDi-!ESt'y'( CAiJ1..K I I
<br />IAT SHr..l I~OCATION
<br />" IREY"SED NOTS: 5
<br />'...... 'RE\-ISEO NO~ S Me-
<br />ITITLE TO R(J:"LECT '-iAI'L
<br />IAL,ER~ATE
<br />
<br />FLO RID A EXTRUDER S I11~~N~lf&1~L'rl~~
<br />CER1lf!CATE or .UTHORIZAne' NO. 92JS SA."iFORD FLORIDA
<br />TrTLE: I'iSTALLATION DETAIL '.1#8 S:::REIIS OR NAllS
<br />HORZ SLIDING FIN WINDDW - SERIES 1000
<br />DRAWN BY: BB I APPROVED Br: RJA
<br />DATE. 12/10/03 'SCALE: N T. S, DWG.: FLEX002B SHEET 1 Of' 2
<br />
<br />12/10/831 R";A
<br />
<br />I
<br />
<br />,~, ",. ",
<br />
<br />~
<br />
<br />~!lS X 3/4 S(L'"
<br />L 1000 S H. TAPPING SM$
<br />H(AD <TYP,)
<br />SEALANT 'ET\lE<N SFC~ION A-A (3,
<br />.;;:- v: ',jDCV rLANGES
<br />\ .I, "iLtLI1JN
<br />\ r 1000 P,w'/DESIGN(R S(,-"t.ANT .9tTVft:E.N
<br />SILL <TYP) V:NDCY r~AN(iES -...,
<br />\ /"8 X 3/4 seLF" r-tULltCN
<br />\. i~ T ~PPING :;MS IS
<br />, (1 X 4 X t
<br />\ rill"" II TeB€: HULUON
<br />
<br />
<br />
<br />
<br />'~':~'Ji'Ji" :i
<br />
<br />"'----1000 S.H.
<br />HtAD (TY?,)
<br />SEC-ION A A (5)
<br />
<br />~.L .. x 3/4 SElr
<br />.,.. AP?!NG SMS
<br />Woo S.J.l.
<br />HEAD (TYP.)
<br />SECTION A-A (6)
<br />
<br />,\000 ~'.,.IJDe:SIGNER ?\tI.I'D(SrGN[R! oi.J~(r{IAR,( ~AH'! APPUES TO H€AO.& SILL 'Hr-iERf 1" X 4"
<br />
<br />/ SIl;T,Y:)X 3,4 SEe' r~"::',"H"C 1'~~l_C;_T'~,;~';>' '''~' DETAIL C \ !<~ry-X 4.'" Tlr8fSHMt.:~lTIQ~'NS--:ARE 0SED
<br />~ / iAPPI~G $M$ rL ~AP"'ING $MS I [ \ i"" ,...,' 'J
<br />
<br />iI''' VII "II I~, ,! (1) (1) it- '\
<br />.JI .11 II r i x 2 x 1/8 dJ' 1 X 2 , 3 B ' - - ]1: I I
<br />~, ,) t:..B€: MlJl<..ICN ~-"3t: ).1l.kL/rSN 'l!..L'...JCI< i, I,. J.1 p,Sr..h....LA..-ION ANCHO~ ~a "'Jot:
<br />~I S(A(..ill{T ;u:....ytt~ J 1 i i / SCP(V (Ti'?)
<br />, V)NnO'. CLANGES , ~ '"TT I
<br />
<br />"'\-: I "~LICN '.11 ~ ~ -I '''0 BY "OOD ~"I i ' -?
<br />\ L-} ..... ,~-f;;{~r~TJ~~~~Jr;
<br />
<br />Sf.:ALANT :l(""Y'C;:NJ , _ I ~.... _ SUCK Bi' S"HERS I. V
<br />,,:~ro'w' 'lANG€S \ !fax ], 4 SI:.r..F #3 :( J 4 ,).;:.L' \ ~
<br />& "'lUICN -toce S..H "'"APP!-'-:G $M$ ''-lcee $j-oI.. -:-APPji'<G S~S
<br />HEAD cry?) HEAD (TrP) ~ 1\1 I II ,~QlICN
<br />\ t~~t~~T Ft~~~nN SECTION A-A (1) SEC~'ON A-A (2) I' ~CI~cL P(:y;~ESluNER 'I ' H<l~ I ~
<br />\ &. ~ULLlDN \
<br />\ rl~CO O""/D(SJGNE~ '--lCCO ?-.,/DE:$[GNE:R j ~ ,.://.
<br />\ I SIlL In?) i Slce Oy>) r~8 x 0/4 sa> ~> '//'r- A .
<br />\ l r~2p~I~/4s~r_r {r~~f'~l~~\;f<.' IL / ,PlPPINQ ~,s/; 2: x " x 3/8 \11\1- I \ __ __ \,
<br />\ / - G rl x a 1/16 x 1/8 !I / r 1 X.2 "7/l6 X 3/s.I,~u.11 H I] TUBE: HULLlCN I lr' r~Ahl/
<br />\0E' I~ II I 'u3€: MCLllON : 'I~ "' Ii / TcaE MULLION - fi--.i1 II ,~ II
<br />
<br />L~:I h' 'I S<AlA'" /1 rlrf I! I' ~- 'I & :1
<br />i . I SC^LANT B<'v"'11 ;.. I" ~~5~"CANGt\, I ~ i I liB' MiN.: i
<br />- ~ ~:~~~ltN~ANQES L-: '- &--J : & l,lUL~'ON \! I I --- ,--.... EMB(l)ME/<fi : ..E~
<br />-1 J) I .ii,1 JI I I }J ~ ,I -i "E,"O "'OM EXTERIOR
<br />- ~ ;l"PQL>€:S TO i-<tAC '" SILL "'HERE \' X 2"
<br />II "- il '\ &: \" X .2 7(' $. Tlj8E MULUCN'$ AAE I.!SE.~
<br />~, '-.8 X 3/' SEl< ~,,---,. X 3/' SE'J ',. ~
<br />'--lOOCSH. iAPP~~GS,'1S '--~:JCOSH. .-APP1NGS....S : """~
<br />H(AD O'"P) ,.LAD (TVf') fZ:~
<br />""FC) ^ (>\ \ 4lS X 3/4 SELF' ~ I~' ! .N.."T~':ON MCJo;CA
<br />~1~lib~T rt~~~gN .:;L!-. Tll N A-~ SECTiON A-A (4J rAPPING $M$ Me "QOO SC~C""
<br />
<br />\ t. MUlLlC~ r lOOO P \JjD(SIGNER S~AlA~T }(;'<f~tN r lOCO P ,.t.lj)(SJGNER - ~~02D s(~"i'P) SECTION A-,A. (7) 1\ "'--(:;:z. C",IP
<br />\ I SI.LL (FP) ~'~eE~c~l~NGE:~1! SLL (TYP) 1 '
<br />\ r. /~9 X 3/4 SELr L1 /#8 X 3 4 S(U" ,I ~I I
<br />\ TAPt:ljN'G $,'"S L I TAPPfNG $MS W<Jyne A. g;.,ck. P E
<br />\. r j x 4 j 1/8 I r 1 x 4 x 3/8 , 548 a H'IIY 27 ~ I Vi' ~1N,
<br />I O\IlELi'EN1
<br />\ Jrlll "II '~aEMULLlG' '!Jf"'111 "il / 'C'E'VL~'JNI it~o;^~.";.o3~;~~3
<br />~I' ,I I,!:, ' FLORIDA EXTRUDERS ~l~~oJ:~'ERo~"I
<br />, 1 !, ", I lNTERNATlONAL INC
<br />I!' 'i "-:;= b ! ".--- TITLE. SER 1000/1500 FIN SHEET 1 Of' 2
<br />"--crl II '----C.LLJ I I ,.')~~~'~\ ~ I' HCRIZJNTA,c. MULU:JN S::C:IDNS
<br />
<br />II " II " I ~ SEE JTHER S 1 DE (SHEET 2 OF 2) 'DR
<br />i '---.a x 0" SELP ~ ""--,a K 3,4 SE'J 0 "'""'3 DESIGt'-J PRESSUi'iE CAPACITIES
<br />"'--"00 SH. 'APP"G ,.", "'--lOOO SH. "PPI'G S"$ '7:'<> :,.: . (\:;. :
<br />HEAD (n?.> HEAn (TfP) I "'(,,', <, '," IDRAWN BY MSH ] APPROVED BY wAB
<br />SECTION A A (5) SECTIO.N A-A (6 ~ ~. ," 'DATE, 12/ 1 /03 I SCALE: NT S 'DWC.' 1 HMF IN
<br />
<br />11000 P,I,t I:lESlGNtR
<br />I SILL (HP) I
<br />n r#9 X JJ4 :sE:LF"
<br />II / ~M'PINW SMS 1 X 4 X JIB I
<br />1"0111 '" II r TlX _UUJCN!
<br />
<br />
<br />~ l. I
<br />JI I I
<br />
<br />.----1
<br />
<br />d. IX OR 2X ~ULL
<br />
<br />I
<br />
<br />'. X~":I.'4:)}'\~'~;" ','. -<'"'
<br />.,'U} -
<br />':1,9~:,~ 111~
<br />
<br />"~. }'~ . \'/"~""
<br />~I' ,',', .,
<br />, ,.~.), ,
<br />
<br />IFLORIDA EXTRUDERSl11~~N~~#<rl~i
<br />, SANFORD FLORIDA
<br />ITITLESER :000/1500 FLANGE SHEET 1 OF 2
<br />, ,ERT:CAL MULLION I~TO HORIZJNTAL
<br />,
<br />: SEE OTHER SlDE (SHEET 2 JF 2) FOR
<br />i DESIGN P~ESSURE CAPACITIES
<br />:IDRA'fN BY. ;>1SH I APPROV/;D BY, ',lAB
<br />DAYEd2/1/03 ISCALE'N'TS IDWG, 1VMHMFLG
<br />
<br />~
<br />
<br />~
<br />
<br />--'
<br />s~~;8\: ~t~'~6~~ ...J/
<br />.. I-lUlLlCN
<br />
<br />(
<br />,"
<br />\. St~~~b~ }l~~fi ~
<br />I. /'Il.,LllCN ,
<br />be x 1~l/2 S€:LF 46 x ,-1/2 SELF
<br />tAPPiN(j S~S 7APPlNG S;MS
<br />A-A (5) SECTION A A (6)
<br />
<br />SECTION
<br />
<br />1 1/4' :-1:N.
<br />EHBEDMENT, .6
<br />
<br />r~
<br />i
<br />
<br />ONE BY ''0/00 D
<br />BUCK BY OTr1ER;\
<br />
<br />. .6\
<br />---
<br />
<br />DETAil C
<br />
<br />r CONeR€: T E: CR MA SONR Y
<br />I, BY QTHERS
<br />.61
<br />
<br />t
<br />
<br />2 X 4 X 3/S \., I I
<br />
<br />'v'ULLUCN in I
<br />CAM~O~T;pH; \1 II
<br />=4 ~
<br />~- -rr
<br />
<br />,
<br />
<br />i :'11 \ \"':NS'ALCA-!CN ANCHOR 3/;,' '"
<br />, ,I ( 'fAPCON SeR('.... ANC(<QR (;"vP)
<br />
<br />I !. I ~- ECEIV'.:AL ~ULUCN
<br />I ' U !~:ST,l,,-LATlON CU~
<br />
<br />, /1' T'i'PICAL MuWON :0 CONCRETE @ HEAO
<br />I _UlLlDN --/' il~,I(Af'PUES TO HOAO!< SILL WHERE 1" X <
<br />i ~/,_lL& z" x 4" ....USe MlI~LIO"'S APE USED)
<br />
<br />I
<br />I
<br />~~p~r~62s~~U' II 'llJ,n r~:~~lD-,~Tl?~p~~~'"c~
<br />I Stl~( '" ANCHCR TY? \
<br />
<br />hi i, 'J\~I rSLLCL~
<br />
<br />r-~ l/~" MIN
<br />~ , . _E"'BEDIo'IE:1>lr
<br />
<br />"'-- :;>R~CAST Sl; B'r o~~~
<br />AUXILJARY ?I_A'"'E
<br />(Ft:R ADD:TJQSA..... I.\,NC,.ORS, ''''1-'e:,~ R'E~UIRt:D)
<br />
<br />DE::'AIL 8
<br />
<br />St:,o,t..ANT BC T\ta:~
<br />W'INDC'."r ::"LAI'<Ge::S
<br />.. ~ULLlaN
<br />SECTION A-A (7)
<br />
<br />~...'>.--\
<br />
<br />I
<br />,
<br />I
<br />I
<br />i
<br />i
<br />i
<br />Iw ~~
<br />IO"......~N
<br />~Nr'";'.()
<br />.x
<br />l~fLi~
<br />II<coc"~
<br />~~ Q ~
<br />I ~1O E!5
<br />i~ ~c:
<br />
<br />II # (t-)
<br />
<br />#
<br />
<br />~lt
<br />!ij-11L0~ {~
<br />'~UCN 'I ---:- I ]
<br />
<br />~ u
<br />
<br />\, /
<br />- "- llilllU
<br />
<br />(#8 sur TAf'PI,\'G
<br />SM$ (TY?)
<br />~
<br />V'EWED FROM EXTERIOR
<br />.'1";': ::;k::l~~'!~i'C;'!:
<br />. ,."4.1:;'.. ,'::,)'.,,-:' ,. 't>>:"
<br />
<br />.~~. ...,-'~
<br />
<br />
<br />',%,,~,
<br />
<br />: ~ ... ..' ! .....!<{~;~'.
<br />
<br />, FLORIDA EXTRUDERS 1~~~'<m,~W'J~~
<br />SA.'lFORD FLORIDA
<br />ITI'!'LE, SER 1000/ 1500 F~ANGE SHEET 1 OF 2
<br />VERTICAL MULLION SECTIONS
<br />SEE OTHER SIDE (SnEET 2 OF 2) FOR
<br />DESIGN PRESSURE CAPACITIES
<br />DRAWN BY. i~SH I APPROI'ED BY: Ii Q.B
<br />DATE:l2/1/03 iSCALE:NTSDWG: lVi'1FLG
<br />
<br />-'.10 gy "ODD
<br />~ 8UCK gy OT"ER~
<br />-------- .
<br />11/8'" Ml't ".
<br />EMgEDMENT . I
<br />I ? I
<br />I
<br />
<br />OETAIL C
<br />
<br />2X4X3/9,\ I
<br />TUBE ,t,.lUl.LlCN \ I
<br />
<br />!n
<br />I I
<br />lOOO S:H. i
<br />JA"! (TYPO 1\ I
<br />
<br />~I if:
<br />l~ -r
<br />
<br />I
<br />I ~
<br />I <"
<br />
<br />Il'l~\ ".
<br />"~$,...,E:ATHl~~G
<br />
<br />I INS.... ~L _A ~ l:;N ANC~OR 1t8 ,,'J01:
<br />I I SCRI:V qyp)
<br />~ I~ E'X ....tR'~A'- ";ULUDN
<br />L-JL ji'.STALLA'rlDN CUo
<br />~uLL m~ 'I
<br />APPLIES fO HEA:> &. SILL WHERE ," x 4ft
<br />!< 2' x 4" "J8E MULUONS ARE USED
<br />
<br />-
<br />
<br />APP1..Jt:S TO rlEAD & SILL WHf:;RE ,.. X 2~
<br />&: ,.. x 27/18' TJBE \,4UI....UONS ARE ',.JSSD
<br />
<br />
<br />DETAIL... 8 ~ r~:~~~;T~~~~C"O.
<br />1~lrS~
<br />/l 8EE ~MiEa;t-1~~1
<br />SHEATHlNC J i --r
<br />I
<br />1 '1008 ,1IAAlt-G
<br />.ALXIUARY PLATE
<br />(fD~ ADDHI!JNAL A.NCHCRS, V\..jOl R:EQUJRE.D)
<br />
<br />~1
<br />~~$.
<br />I : : ~ ___ ___8~ ~l
<br />
<br />.s SELF 1 APPING./ \, -( _ULUQN;I I' ~I'
<br />SHS (TYP,) JlElAlLi
<br />VIE'NEDELF'i{t~O&rERIOR ~
<br />411'>::. ::"'{0 IFLORIDA EXTRUDERSlN'l'ERNATIONAL.INC
<br />; ,,1',' )>" . 'V< ~~~~o~rifERo~I
<br />, ;).,".~. :TI'!'LE' SER 1000/1500 FIN SHt:ET 1 or 2
<br />1 'VERTICAl MULLION SECTIONS
<br />I SEE OTHER S I DE (S'-'EET 2 OF 2) FC:R
<br />DESIGN PR>SSURE CAPACITIES
<br />, . jDRAWN BY: MSH i APPROVED BY wAS
<br />,," , " OATE:12/1/03 [SCALE, NTS ,OWG.: 1 VHF IN
<br />
<br />#9 X U~ seLF
<br />: APPING SMS
<br />
<br />(C; \
<br />
<br />'8 X 1-:/2 SE'P~"'''''
<br />T APP LNG SMS
<br />
<br />";;JI
<br />
<br />.----sEALANT iET'JtEN
<br />"n,.DCIoI rlANGES
<br />.. ~UlL1DN
<br />
<br />SECTION A-A (7)
<br />=aILL",\- ,
<br />
<br />#
<br />
<br />[Jl # I
<br />
<br />Iw =;3
<br />
<br />Ia: r-... ~~
<br />, "NI"')~
<br />'.x
<br />
<br />!~fa:i
<br />
<br />.... co _" ~
<br />~ ""
<br />
<br />~~ ~~
<br />o ~
<br />:: J~
<br />
<br />TiPleAl MULLION T, CONCRElr 'it JAMS ~
<br />(APPliES TO JAMB WHER'E ,. X 4 ~ T
<br />It 2" X 4" TUBE MULLIONS ARE USED) 'J
<br />
<br />
<br />'\ I
<br />CONCRETE: CR MASOr..R'( --....... I I
<br />BY OTHERS .......... 0
<br />\ :;
<br />
<br />OE::'All 8
<br />
<br />:NS T ,ilL _A T !C~ ANCHOR J/IG! 131A.
<br />T4P':ON SCREV ANCI-'O~ (T1''',)
<br />. \\ !i ~EXTERNAI... MULL[!J1It
<br />ONE 2'1' ......'JO~~ \ i~ :NS'"At.'_ATICN CUP
<br />BUCK BY DTHERS c-1 \ !~~
<br />
<br />'" \I~
<br />~ --- _CUCN
<br />I. I liU
<br />J ~"'"
<br />
<br />EI-iB(:~E:N.T
<br />
<br />,
<br />J I II
<br />
<br />I
<br />i
<br />
<br />~~\
<br />(I ' I
<br />\H~I
<br />:!# II
<br />Ii
<br />
<br />~#a x 3/4 SElf"
<br />i >\PP1NG Sl"!S
<br />SECTION A-A
<br />
<br />(7)
<br />
<br />lOCO S.H.
<br />HEAD (iY?)
<br />
<br />i
<br />WO~4~ AS ~l~~k'2;.E, I
<br />Clermont, Fl 347 i 1 !
<br />~~ license No. :5258~;> c. 11 FLORIDA EXTRUDERS I11~~'lffi?EW'rl~~
<br />.; '." SANFORD FLORID.'
<br />.~. 'mLE'SER, 1000/ 15JO F ~A'iGE SHEET 1 OF 2
<br />HORIZONTAL MULLISN SECTIONS
<br />
<br />~
<br />\/1t:NED i:"ROM EXTERJ0R
<br />
<br />I ~~
<br />.y
<br />
<br />1='
<br />
<br />SEE OTHER SIJE (SHEET 2 OF 2) FOR
<br />DESIGN PRESSURE CA,PACITIES
<br />
<br />DRAWN BY: MSH I APPROVED BY' ".AS
<br />DAYEd2/1/03 jSCALE:NTS IDWG., lHMFlG
<br />
<br />w
<br />()
<br />I-
<br />o
<br />Z
<br />w
<br />~
<br />f5
<br />o
<br />o
<br />u..
<br />W
<br />0::
<br /><(
<br />::)
<br />CY
<br />Cf)
<br />
<br />w
<br />~
<br />u...-:t0::
<br />-00::0
<br />w u...Ll.
<br />I- W '
<br />-:tQ~Z
<br />~-O:::J
<br />X~O::O
<br />O:::JLl.U
<br />O::OZU
<br />o..."",W-:t
<br />0...""'~1-
<br />-:to-:t0
<br />WO::I-Z
<br />o::Ll.W
<br />-:tZO::O
<br />QW-:tQ
<br />W::C:(J)O
<br />I-~ZZ
<br />o O-:t
<br />:::JW-W
<br />O'O::(J)"",
<br />-:tZ.o:::
<br />f:3(J)W-:tZ
<br />~z~8:o
<br />~QOOi=
<br />O(J)O::I-(S
<br />OEijQ~::J
<br />Ll.""o::Uo...
<br />W:::;wOo...
<br />D:::QI-05-:t
<br />-:t-l~ ...J
<br />:::J -l _ 0:: -l
<br />0' -:t (J) 0 <(~
<br />(J)0::...J'-
<br />W-lQ
<br />::::J>:$ZO::
<br />-:to;>-:tQ
<br />
<br />W <.:l
<br />I ~ ~
<br />f-_(/) ~ c,c
<br />~ZW -:tc,cM
<br />(/)~QQ 0::("Ic,c
<br />. rorl-O Q.-l'lj:
<br />0::'---'....... (J)(/)...J
<br />WZ.....U w_Lnu.
<br />~~1f<.:l :r:I~.
<br />:':::(,/)-2 1-1-....1.1.I
<br />00::()CS 0::u..u.Q.
<br />2W~-l 00..
<br />WO(J)5(/)Ll.z~C5
<br />WZ(J)COZOO ~O
<br />I:;)ZwQ::Ji=zct
<br />1-0-:t:r:(J)-:t0::=::;)
<br />Ou..Z...JI->wOOtQ
<br />-:t 0... :r: W (/) Q... 0:: .
<br />I-W:;;!I-O::O....Jca'-'l
<br />(/),"'.....- -:t...J
<br />W '-' 0:: 3: ('<') Z 0:: . lJJ
<br />COO:;) O<t::;)<~
<br />W::]I->-OOI-....::c
<br />;r:03:~~~~~~~
<br />r- O::""'I-~O::Oc::::
<br />2~tn8~u;t;DD
<br />
<br />.
<br />
<br />~~-l
<br />Cl)1U~
<br />CU.- 0
<br />C1)(,)V;
<br />~ ~ ~
<br />I U) ~
<br />Cl)CUo...
<br />~ fo~
<br />C'CS.- i=
<br />~U)o::
<br />OQ)~
<br />e"C
<br />~W 52~
<br />~~~
<br />f-I. 'X;;/ J J.
<br />~~
<br />II ~ a;
<br />(!)~
<br />
<br />iQ ,= 10'''
<br />~<(CO
<br />U;
<br />W
<br />o
<br />o
<br />Z
<br />o
<br />-l
<br />:;)
<br />CO
<br />
<br />....J
<br /><(
<br />0::
<br />I-
<br />~
<br />o
<br />(J)
<br />(J)
<br />o
<br />....J('<')
<br />COo
<br />wI'--
<br />0'"
<br />Z('<')
<br />-:t....J
<br />cr:Ll.
<br />o -
<br />.~
<br />(/)0...
<br />LOO
<br />'<:to...
<br />O)-:t
<br />
<br />w
<br />()
<br />~~
<br />('<')~
<br />('<')0
<br />('<')('<')
<br />"''''
<br />00
<br />coco
<br />COCO
<br />~~
<br />00
<br />~'<:t
<br />
<br />ff-B
<br />
<br />CJ
<br />Z
<br />-
<br />
<br />0)
<br />o
<br />('<')
<br />'"
<br />o Z
<br />CO 0
<br />O? ~
<br />...: I'-- N ....
<br />I- O(J)'- 0
<br />E ~o::o:: 0
<br />o ><wO '"
<br />Vl <W:r:
<br />Vl u... Z I- .-H
<br />Q('<')LO(3~ .-H
<br />~~~ZLl. Q)
<br />~",,,,WO .0
<br />C ('<') , ....J W .9
<br />CO <;t -:t I- U
<br />0.... u: .-H 0:: -:t.-H 0
<br />CO:;)U
<br />. co- ~ r- - <.0
<br />(J).xOU~~ w"
<br />0.. ~ :::J f- ...,
<br />.-H 0 0:: cr: ' I-
<br />LO a.:r: I- W 0 -:t
<br />O)-:tQ...(J)()Z 0
<br />
<br />ui
<br />z
<br />o
<br />j:
<br />::;)
<br />.....
<br />o
<br />(I)
<br />z
<br />CJ
<br />~
<br />o
<br /><
<br />c
<br />IX
<br />o
<br />Li
<br />
<br />o
<br />o
<br />Z \0
<br />o w
<br />- I-
<br />U1 S 0
<br />~U1~t'
<br />CJc:i7~
<br /><t ~ 0\ lfl
<br />(J OJ 0 J
<br />- \JJ 0\
<br />~ w M \0
<br />o ~ ('11 t'
<br />o I
<br />..J1...JM
<br />u. Ul u. ..-
<br />..J I- ~ CO
<br /><t: Ul !l I
<br />~ W ....
<br />I- ~ ~
<br />Z . I-
<br />W Z
<br />U 0
<br />o
<br />\0
<br />
<br />o
<br />z W
<br /><;) Z
<br />Ui~~ 0
<br />lJ.Il-(/)w:::i
<br />OZ(/)==~
<br />aO-:r:>
<br />Z2:!::~(/)
<br /><l:NWCX:~
<br /><;)""':;;:00
<br />~cx:aoo
<br />~2w:::U
<br />;ia~~~
<br />O:Jcx:(/)~
<br />~;;focx:
<br />2~;;;:~i3
<br />
<br />N
<br />.
<br />l.!)
<br />N
<br />~
<br />
<br />(/)
<br />Z
<br />o
<br />(/)
<br />>
<br />W
<br />CC
<br />
<br />w
<br />o
<br />
<br />~
<br />o
<br />>-f:Ez
<br />Z 0
<br />-:t~_
<br />ZW~
<br />-(J)>
<br />OZO
<br />t30-:t
<br />:JUO
<br />OZo::
<br />oWo
<br />0::1-...,J
<br />o..!::u...
<br />wO::....J
<br />O::~-:t
<br />wwO::
<br />coJ:1-
<br />I-I-Eij
<br />Ol-U
<br />z:;)
<br />>-00..
<br />-:tIO::
<br />~!::O
<br />z~u
<br />::iffi~
<br />o...zo
<br />~~J:
<br />2=~~
<br />
<br />w
<br />~
<br /><t
<br />z
<br />z
<br />j
<br />Q..
<br />
<br />(f)
<br />-I
<br />
<br />-
<br />
<br /><(
<br />t-
<br />W
<br />o
<br />
<br />I-
<br />o
<br />z
<br />
<br />l-
<br />I
<br />~
<br />
<br />0::
<br />>-
<br />0..
<br />o
<br />()
<br />
<br />SHEET NO.
<br />
<br />0...
<br />0::
<br />o
<br />U
<br />l1J
<br />:2:
<br />o
<br />I
<br />(/)
<br />:::J
<br />('<')
<br />o
<br />o
<br />'"
<br />
<br />@
<br />
<br />5-14
<br />
<br />LAST PLOT DATE
<br />October 11, 2004
<br />
<br />WINDOW INSTALLATION
<br />INSTRUCTIONS (MilESTONE)
<br />
|