|
PLUMBING GENERAL NOTES
<br />1. FURNISH ALL LABOR, MATERIAL, AND EQUIPMENT REQUIRED FOR THE
<br />COMPLETION AND OPERATION OF ALL SYSTEMS IN THIS SECTION OF WORK IN
<br />ACCORDANCE WITH ALL APPLICABLE CODES.
<br />2. ALL PLUMBING FIXTURES AND PLUMBING SYSTEM EQUIPMENT SHALL BE
<br />PROVIDED COMPLETE WITH ALL ACCESSORIES, HANGERS, VALVES, STOPS,
<br />TAILPIECES, TRAPS, FAUCETS, STRAINERS, ETC. SEE FIXTURE SCHEDULE.
<br />3. FURNISH AND INSTALL COMPLETE SYSTEMS OF SOIL, WASTE, VENT, HOT AND
<br />INFIXTURES,AN / HER EQUIPMENT.
<br />GOLD WATER PIPING FROM ALL PLUMBING OR OTHER
<br />AND/OR
<br />INSTALLED IN ACCORDANCE WITH PLUMBING
<br />4. CLEANOUT PLUGS SHALL BE T LLED CCORD G
<br />CODE REQUIREMENTS. PROVIDE CLEANOUT5 AT THE BASE OF ALL WASTE STACKS,
<br />AT EVERY FOUR 45 DEGREE TURNS, AND AT EVERY 100 FEET. CLEANOUTS SHALL
<br />BE PLACED IN READILY ACCESSIBLE LOCATIONS.
<br />5. ALL SOIL, WASTE, AND VENT LINES SHALL BE CONCEALED IN THE BUILDING
<br />CONSTRUCTION.
<br />6. COPPER PIPING SHALL BE PROTECTED AGAINST CONTACT WITH MASONRY OR
<br />DISSIMILAR METALS. ALL HANGERS SUPPORTS ANCHORS AND CLIPS SHALL BE
<br />COPPER OR COPPER PLATED. WHERE COPPER PIPING 15 CARRIED ON IRON
<br />TRAPEZE HANGERS WITH OTHER PIPING, SATISFACTORY AND PERMANENT
<br />ELECTROLYTIC ISOLATION MATERIAL SHALL PROTECT THE COPPER AGAINST
<br />CONTACT WITH OTHER METALS.
<br />7. WHERE COPPER PIPING 15 SLEEVED THROUGH MASONRY, SLEEVES SHALL BE
<br />COPPER OR RED BRASS. WHERE COPPER MUST BE CONCEALED IN A MASONRY
<br />PARTITION OR AGAINST MASONRY, CONTACT SHALL BE PREVENTED BY COATING
<br />THE COPPER HEAVILY WITH ASPHALTIC ENAMEL AND PROVIDING 15# ASPHALT
<br />SATURATED FELT BETWEEN THE PIPE AND MASONRY.
<br />8. THE PLUMBING CONTRACTOR SHALL COORDINATE CLOSELY WITH THE
<br />MECHANICAL AND THE ELECTRICAL CONTRACTORS TO AVOID CONFLICT WITH OTHER
<br />TRADES.
<br />9. CEILING AREA HAS LIMITED SPACE. CONTRACTOR MUST COORDINATE WITH
<br />OTHER TRADES FOR ALL STRUCTURES, PIPING, CONDUIT, DUCTWORK, LIGHTING,
<br />ETC. TO PROPERLY BE INSTALLED.
<br />10. ALL PIPE INSULATION SHALL RUN CONTINUOUSLY THROUGH FLOORS, WALLS,
<br />AND PARTITIONS.
<br />II. PROVIDE DRAIN VALVES IN THE HOT AND COLD WATER SYSTEM AT ALL LOW
<br />POINTS TO ALLOW FOR COMPLETE DRAINAGE.
<br />12. VACUUM BREAKERS SHALL BE PROVIDED FOR ALL FIXTURES TO WHICH HOSES
<br />MAY BE ATTACHED. VACUUM BREAKERS SHALL BE PERMANENTLY ATTACHED.
<br />13. WASTE AND VENT PIPING SHALL BE AS FOLLOWS:
<br />BELOW SLAB: IF ALLOWED BY AHJ: SOLID WALL PVC PIPE, PVC SOCKET
<br />FITTINGS, AND SOLVENT -CEMENTED FITTINGS.
<br />ABOVE SLAB: IF ALLOWED BY AHJ; PVC PIPE, PVC SOCKET FITTINGS, AND
<br />SOLVENT -CEMENTED FITTINGS.
<br />BELOW SLAB: IF PVC IS NOT PERMITTED; SERVICE WEIGHT HUB AND SPIGOT
<br />CAST IRON PIPING WITH HUB AND SPIGOT CAST IRON FITTINGS AND
<br />COMPRESSION GASKETS ABOVE SLAB: SERVICE WEIGHT NO -HUB CAST IRON
<br />PIPING WITH CAST IRON FITTINGS AND HEAVY DUTY BANDS.
<br />14. STORM PIPING SHALL BE AS FOLLOWS:
<br />BELOW SLAB: PVC PIPE, PVC SOCKET FITTINGS, AND SOLVENT -CEMENTED
<br />FITTINGS.
<br />ABOVE GROUND: SERVICE WEIGHT NC -HUB CAST IRON PIPING.
<br />INSULATION IS REQUIRED ON ALL ROOF DRAIN BODIES AND HORIZONTAL RUNS
<br />(ABOVE SLAB). yz THICK RIGID MOLDED FIBERGLASS WITH FITTINGS INSERTS,
<br />PVC COVERS, AND VAPOR BARRIER JACKET.
<br />15. DOMESTIC WATER PIPING ABOVE AND BELOW SLAB SHALL BE PEX TUBING.
<br />INSULATION 15 REQUIRED ON ALL WATER SUPPLY PIPING ABOVE FINISHED FLOOR
<br />WITH INSULATION HAVING A MINIMUM R FACTOR OF 6.5 DETERMINED AT 75'F IN
<br />ACCORDANCE WITH ASTM C-177 OF NC INTERNATIONAL PLUMBING CODE OR PER
<br />LOCAL JURISDICTION.
<br />16. INVERT ELEVATIONS SHALL BE ESTABLISHED AND VERIFIED BEFORE WASTE
<br />PIPING IS INSTALLED 50 THAT PROPER SLOPES WILL BE MAINTAINED.
<br />17. THE PLUMBING CONTRACTOR SHALL PROVIDE WATER HAMMER PROTECTION ON
<br />ALL WATER DISTRIBUTION PIPING WHERE QUICK -CLOSING VALVES ARE UTILIZED.
<br />INSTALLATION OF AIR CHAMBERS OR SHOCK ARRESTORS SHALL BE IN ACCORDANCE
<br />WITH PDI-WH2O1. SEE SHOCK ARRESTOR SCHEDULE (IF PROVIDED).
<br />18. PROVIDE FULL PORT VALVES IN ALL BRANCH LINES OF THE HOT AND COLD
<br />WATER DISTRIBUTION SYSTEM ON �4" AND LARGER CW 4 HW AND AS SHOWN ON
<br />PLANS, RISERS, AND SCHEMATIC DETAILS.
<br />19. REFER TO ARGHITECTURAL DRAWINGS FOR MOUNTING HEIGHTS OF PLUMBING
<br />FIXTURES.
<br />20. PROVIDE ACCESS DOORS FOR ALL VALVES AND DEVICES REQUIRING ACCESS
<br />WHEN LOCATED IN WALLS OR ABOVE INACCESSIBLE CEILING CONSTRUCTION.
<br />21. PROVIDE DEEP SEAL TRAPS FOR ALL FLOOR DRAINS.
<br />22. WHERE EARTHQUAKE LOADS ARE APPLICABLE IN ACCORDANCE WITH THE
<br />PLUMBING CODE, PIPING AND EQUIPMENT SUPPORTS SHALL BE DESIGNED AND
<br />INSTALLED FOR THE SEISMIC FORCES IN ACCORDANCE WITH THE
<br />BUILDING CODE.
<br />23. PROVIDE A U.L. L15TED ASSEMBLY FOR ALL PENETRATIONS THRU FIRE
<br />RATED WALLS AND FLOORS.
<br />24. PROVIDE PRESSURE REDUCING VALVE IF PRESSURE EXCEEDS 80 PSI.
<br />25. ALL SUSPENDED MATERIALS AND EQUIPMENT SHALL BE INDVIDUALLY
<br />SUPPORTED FROM THE BUILDING STRUCTURE. DO NOT SUSPEND ITEMS FROM THE
<br />CEILING OR ITS SUPPORT SYTEM.
<br />2
<br />E
<br />m
<br />v
<br />�t:
<br />O q
<br />d U')
<br />3
<br />O
<br />I PLUMBING I ND
<br />-
<br />DOMESTIC COLD WATER PIPING
<br />---
<br />115 DOMESTIC HOT WATER PIPING
<br />-
<br />- - - - -
<br />VENT PIPING
<br />WASTE (SANITARY SEWER)
<br />FULL PORT VALVE
<br />f
<br />CHECK VALVE
<br />PIPE UP
<br />9
<br />PIPE DOWN
<br />FIXTURE DESIGNATION
<br />13
<br />FLOOR DRAIN
<br />ABV
<br />ABOVE
<br />AFF
<br />ABOVE FINISHED FLOOR
<br />AHJ
<br />AUTHORITY HAVING JURISDICTION
<br />CW
<br />COLD WATER
<br />DN
<br />DOWN
<br />E.C.
<br />ELECTRICAL SUB -CONTRACTOR
<br />E L
<br />FCO
<br />FLOOR CLEAN OUT
<br />FD
<br />FLOOR DRAIN
<br />FPHB
<br />FREEZE PROOF HOSE BIBB
<br />FR
<br />FROM
<br />G.C.
<br />GENERAL CONTRACTOR
<br />GCO
<br />GRADE CLEAN OUT
<br />HB
<br />HOSE BIBB
<br />HW
<br />HOT WATER
<br />M.C.
<br />MECHANICAL SUB -CONTRACTOR
<br />P.C.
<br />PLUMBING SUB -CONTRACTOR
<br />V
<br />VENT
<br />W
<br />WASTE
<br />WCO
<br />WALL CLEAN OUT
<br />PLUMBING FIXTURE SPECIFICA11ONS AND CONNECTION SCHEDULE
<br />FAUGET'NALVE DRAIN BPS PIPE SIZES j
<br />MARK FIXTURE TYPE MANUFACTURER MODEL NO. MATERIAL STYLE - MANIFACT._ ---__ -_ __� .__..__ ___ _._- __-- MOUPtTINCs i REPU►WC5
<br />MODEL. NO. SPOUT IEWNDLES CENTERS', TYPE SUE AND STOPS iWA51'E VENT] CW FW
<br />F
<br />WATER FLUSH AMERICAN CAp VITREOUS HANDICAP _ _ _ _ _ _ McQUIRE " ` " ' " _ _ PROVIDE WITH OLSONITE #q5
<br />WC CLOSET TANK STANDARD 4 2 ( FLOOR (SEAT. SEE NOTE I.
<br />2998.012 CHINA ELONGATED 166LK
<br />f j •
<br />WALL AMERICAN VITREOUS HANDICAP DELTA SINGLE " " McQUIRE u " " " ; WALL
<br />A�1/ LAVATORY HUNG STANDARD 0124.024 CHINA SHELFBACK 523 WF NDF STANDARD LEVER 4 GRID I 185 lye I %� HUNG SEE NOTE 2.
<br />}
<br />I �
<br />Y
<br />'i t 4
<br />-
<br />PROVIDE TMOP`-HANGER WANDVAO
<br />L MOP SINK
<br />FLOOR
<br />MUSTEE
<br />19F MOLDED
<br />20" X 24" MU5TEE
<br />TWO
<br />THREADED 4" - -
<br />- 3" lye' 3i4" 14 FLOOR
<br />BREAKER. ALSO INCLUDE WALL
<br />MOUNTED
<br />PLASTIC
<br />34" HIGH 93.600
<br />HANDLES
<br />HUNG SPRAYER W/ NOSE: TtS
<br />... .._.
<br /># -
<br />HOSE
<br />BIBB
<br />STANDARD WOODFORD
<br />24P CAST
<br />BRASS
<br />WALL _
<br />FAUCET
<br />_ L005E
<br />KEY
<br />WALLINTERGRAL
<br />VACUUM BREAKER
<br />WALL
<br />FPHB
<br />FREEZE J.R.SMITH
<br />`� CAST
<br />BOX
<br />LOOSE"
<br />WALL
<br />PROVIDE WITH INTEGRAL
<br />HYDRANT
<br />PRE
<br />BRA55
<br />FAUCET
<br />KEY
<br />VACUUM BREAKER.
<br />_
<br />................ ................... . - _ . .... _._ ...
<br />WCO WALL
<br />ROUND JOSAM 58890
<br />STAINLESS j
<br />BRONZE
<br />WALL
<br />CLEAN -OUT
<br />_
<br />TOP
<br />._.._..
<br />STEEL
<br />PLUG
<br />__ _ _
<br />FLOOR
<br />f GO
<br />SQUARE JOSAM 56030
<br />CAST
<br />BRONZE - - - - - - - :. FLOOR
<br />CLEAN -OUT
<br />._._... .._._......,_... ........_ .__.
<br />TOP
<br />_. ...._.
<br />IRON
<br />_.....................................__..._...
<br />PLUG ! t
<br />E
<br />.. .. ........._.... .,........... ...........__. .. .... ... ......... .. ......... ... ... .......... ... .............._..._..............._.. .. ............... _.__.... ...._ ..... ___..... .....___..__...._............_............_.
<br />aQ
<br />GRADE ROUND JOSAM 56040 CAST BRONZE - _ _ _ _ _ _ _ _ _ _ PROVIDE 24'X24"X4" THICK
<br />CLEAN -OUT' TOP IRON PLUG GRADE ;CONCRETE PAD AT GRADE.
<br />FLOOR SQUARE CAST NIKALOY '
<br />FLOOR FD nnAIkI T.,r, J.R. SMITH 2O10 ;PROVIDE WITH TRAP PRIMER
<br />- _ --
<br />NOTES:
<br />1. SEE ARCH. ELEVATIONS FOR TRIP LEVER LOCATION. INSTALL TRIP LEVER TO WIDE 51DE OF STALL. SPECIFY TRIP LEVER LOCATION WHEN ORDERING.
<br />2. INSULATE HOT AND COLD WATER SUPPLIES AND P-TRAP WITH TRUEBRO MODEL 102 INSULATION KIT. PROVIDE WITH POINT OF USE MIXING VALVE (LAWLER, MODEL #516) SET @ 105'F.
<br />3. PROVIDE �4"HW SUPPLY PIPING WITH SHUT-OFF VALVE TO WALL HUNG HOSE SPRAY (ADJACENT TO MOP SINK). SEE MOP 51NK (5-1) FOR ADDITIONAL INFORMATION.
<br />VACUUM
<br />BREAKER
<br />"LAWLER, MODEL# 66-25" MIXING VALVE -\
<br />SHUT-OFF
<br />VALVE
<br />UNION (TYP)
<br />lye" DEEP GALV. WATER
<br />DRAIN PAN HEATER
<br />SET @ 140,
<br />I" DRAIN LINE
<br />TO MOP SINK
<br />C.W. MAKE-UP
<br />120'
<br />H.W. TO FIXTURES
<br />"AMTROL" EXPANSION TANK
<br />TEMPERATURE AND
<br />PRESSURE RELIEF VALVE
<br />WATER HEATER ON PLATFORM BY
<br />G.C. SIZE PER LOCAL SEISMIC
<br />REQUIREMENTS AND TOTAL WEIGHT
<br />OF WATER HEATER FULL OF WATER.
<br />HB "-DISCHARGE FULL SIZE OF VALVE
<br />DISCHARGE TO MOP SINK WITH ELBOW
<br />TURNED DOWN
<br />DWATER HEATER DIAGRAM
<br />NO SCALE
<br />NOTE:
<br />I. INSTALL WATER HEATER PER MANUFACTURER REQUIREMENTS.
<br />2. PROVIDE HEAT TRAP ON CW AND HW LINES PER INTERNATIONAL
<br />ENERGY CONSERVATION CODE , 5ETION C404.3.
<br />ENGINEERING
<br />2923 South Tryon Street Suite 280
<br />Charlotte, North Carolina 28203
<br />tel 704.373.0068 fax 704.373.0260
<br />MECHANICAL ELECTRICAL. PLUMBING
<br />%%011r,nu111111*0
<br />11
<br />ATE OF
<br />,
<br />no
<br />L
<br />IIIII1RAMp`27, 2021
<br />^ I0-
<br />V) n
<br />WJ 0
<br />V
<br />Z
<br />Z�-
<br />Z
<br />i- W
<br />__l
<br />ULn
<br />co 0
<br />WCO J
<br />_IN-j w
<br />a
<br />O1--wo
<br />Qu) 0 .,
<br />L0 F- J Z a
<br />W = 0 za
<br />W
<br />i� JJ
<br />N 0
<br />oy��OLt� a
<br />tlI
<br />rat
<br />od aw RNA on agrt. b. Cman'
<br />J�e1
<br />aop %ht 201,% cm" "OWN
<br />N000ioM.
<br />o ded �wrtom ate'
<br />REV. I DESCRIPTION
<br />09-23-2021
<br />SCHEDULE, NOTES
<br />AND LEGENDS
<br />pml
<br />N r
<br />N
<br />
|