|
120
<br />100
<br />so
<br />60
<br />40
<br />20
<br />0 4
<br />0
<br />PENTAIR EQ SERIES PERFORMANCE CURVE
<br />EQ1000
<br />100 200 300 400 Soo 600
<br />FLOW RATE IN U.S. GPM
<br />RECIRCULATION PUMP CURVE
<br />--so
<br />70
<br />-20
<br />Z m 0,
<br />WCL =
<br />y 'n
<br />z
<br />uj
<br />_-20
<br />- 10
<br />0
<br />700
<br />MARK
<br />DESCRIPTION
<br />VOLTAGE
<br />MANUFACTURER & MODEL NO.
<br />MAIN LUG BREAKER PANEL
<br />(24 CIRCUIT)
<br />120/240V
<br />SIEMENS, PW2442L3200CU
<br />RECIRCULATION PUMP
<br />208-230/460V
<br />PENTAIR, EQKT1000, 10 HIP
<br />100 W SERVICE LIGHT FIXTURE
<br />115V
<br />INTERMATIC, VPXG11GCI 10OW
<br />CHLORINE FEEDER PUMP
<br />115V
<br />STENNER, 8SMS
<br />ACID FEEDER PUMP
<br />115V
<br />STENNER, 45MS
<br />SERVICE GFCI
<br />115V
<br />PASS & SEYMOUR
<br />CHEMISTRY CONTROLLER
<br />115V
<br />CES, MR3
<br />DECK JET PUMP
<br />208-230/460V
<br />SPECK, 95X, 7.5 HIP
<br />BUBBLER PUMP
<br />208-230/460V
<br />PENTAIR, MAX-E-PRO XF VS, 5 HP
<br />EXHAUSTFAN
<br />115V
<br />DAYTON 273 CFM
<br />POOL LIGHTING (11)
<br />115V
<br />AMERITILITE, 10OW LED EQUIVALENT
<br />POOL LIGHTING TRANSFORMER (3)
<br />115V
<br />PENTAIR, PX300 30OW TRANSFORMER
<br />CHLORO-SAUNE GENERATOR
<br />115V
<br />CES, CHLOAKING SM15.0
<br />FEATURE TIMER (2)
<br />115-208/230V
<br />INTERMATIC, T-101, 24 HR MECH TIMER
<br />ELECTRICAL SPECIFICATION PROVIDE BY
<br />AQUAWORX USA
<br />4
<br />FIELD CAST 6" THICK, 2500.
<br />CONCRETE FOOTING UNDER
<br />STEEL FRAME & COVER
<br />FILTER EQUIPMENT CABINET
<br />SAND FILTERS SET ON CONCRETE PAD
<br />4,000 PSI CONCRETE
<br />#3 REBAR @ 6" O.C.E.W.
<br />6" THICK MIN.
<br />SIDEWALL VENT
<br />(TYP BOTH SIDES)
<br />1" x I" STEEL FRAME
<br />FRAME ON BRICKS
<br />AS NEEDED
<br />u-1-1 I I w vv I
<br />(TYP OF 3)
<br />SAND FILTER EQUIPMENT SCHEMATIC LAYOUT
<br />FEEDER & CIRCUIT SCHEDULE:
<br />CONDUCTORS
<br />MARK
<br />PHASE
<br />NEUTRAL
<br />GROUND
<br />CONDUIT
<br />REMARKS
<br />PANEL FEED
<br />A2
<br />348
<br />1 - #8
<br />ill
<br />UL SEALTITE
<br />3410
<br />1-#10
<br />1/2"
<br />SEALTITE TO PANEL
<br />AA3
<br />4
<br />1412
<br />1-#12
<br />1-#12
<br />1/2"
<br />SEALTITE TO LIGHT
<br />AS
<br />1412
<br />1-#12
<br />1-#12
<br />1/2"
<br />SEALTITE TO PANEL
<br />A6
<br />1412
<br />1-#12
<br />1-#12
<br />1 1/2"
<br />1 SEALTITE TO PANEL
<br />CONDUCTORS AND CONDUIT INSTALLED BY OTHERS
<br />PANEL SCHEDULE:
<br />THREE PHASE, 4-WIRE -- 208Y/120 VAC OR 240 VAC INSULATED/BONDABLE NEUTRAL
<br />CURRENT WITHSTAND RATING MAX. RMS. SYMI. 10,OOOA 12/240V
<br />CIRCUIT
<br />POLE
<br />TRIP
<br />LOAD
<br />AMPS
<br />1-3
<br />3
<br />50AGFI
<br />RECIRC. PUMP W/(2) INTERLOCKED CHEM. CONT
<br />29.8
<br />4-6
<br />3
<br />SOAGFI
<br />DECKJETPUMP
<br />19.9
<br />7-9
<br />3
<br />30A GFI
<br />-BUBBLER PUMP
<br />13.8
<br />10
<br />1
<br />20AGFI
<br />POOL LIGHT TRANSFORMER #1
<br />10.0
<br />11
<br />1
<br />20A GF1
<br />POOL LIGHT TRANSFORMER #2
<br />10.0
<br />12
<br />1
<br />20AGFI
<br />POOL LIGHT TRANSFORMER #3
<br />3.3
<br />13
<br />1
<br />20A GFI
<br />CHLORO SALINE GENERATOR
<br />7.5
<br />14
<br />1
<br />20A
<br />SERVICE LIGHT
<br />1.5
<br />15
<br />1
<br />20A
<br />SERVICE GFCI
<br />3.0
<br />16
<br />1
<br />20A
<br />EXHAUST FAN
<br />3.1-
<br />SPARE
<br />TOTAL MAXIMUM LOAD
<br />101.9
<br />FILTER EQUIPMENT CABINET
<br />FRONT ELEVATION
<br />FILTER TANK
<br />FRONT ELEVATION
<br />132"
<br />FILTER EQUIPMENT CABINET
<br />PLAN
<br />b
<br />LABELED- LABELED:
<br />"ACID" "CHLORINE"
<br />A
<br />DECK JET PUMP
<br />(9
<br />1" FROM SALINE
<br />6" FLOWMETER- 3" FROM HEATER
<br />THERMOMTER- 6" DECK JET SUCTION
<br />CHEMICAL INJECTION POINTS- - 3" TO HEATER
<br />6" RECIRC RETURN TO POOL- 1" FROM SALINE
<br />4" DECK JET RETURN - 6" RECIRC RETURN FROM FILTER PACK
<br />10OW SERVICE LIGHT F BUBBLER PUMP
<br />. ......... .
<br />SALT CHLORINE GENERATOR
<br />0 0
<br />ELECTRICAL PANEL---;
<br />...........
<br />SALT CHLORINE CONTROLLER
<br />VFD f
<br />VFD CHEMISTRY CONTROLLER
<br />EXHAUST FAN
<br />CHLORINE FEEDER
<br />6" RECI RC SUCTION un! nc:)
<br />4
<br />pH FEEDER
<br />__�3- �BUBBLER RETURN
<br />RECIRC P1 IMP - 6" RECIRC RETURN TO FILTERS
<br />4" BUBBLER SUCTION
<br />FILTER EQUIPMENT CABINET
<br />PLAN
<br />26'
<br />60
<br />NotKutiAllmu MUUINltu
<br />ALUMINUM RAILING
<br />EQUIPMENT COVER
<br />SIDE ELEVATION EQUIPMENTCOVER
<br />SIDE ELEVATION
<br />BACKWASH SUMP DETAIL
<br />VACUUM FILTER ELEMENTS
<br />(TYP OF 5)
<br />6" DECK JET PUMP SUCTION
<br />4-1
<br />NOTES:
<br />1. PLUMBING - ALL PIPE & FITTINGS SHALL BE SCHEDULE 40 PVC PER ASTM D1785 AND N.S.F. APPROVED AND STAMPED FOR
<br />POTABLE WATER APPLICATIONS. JOINTS TO BE SOLVENT WELDED PER ASTM D2855. ALL PLUMBING AND MATERIALS TO CONFORM
<br />TO FLORIDA BUILDING CODE 2020 - SEVENTH EDITION.
<br />2. ELECTRICAL - ALL ELECTRICAL EQUIPMENT WIRING, INSTALLATION AND GROUNDING OF POOL COMPONENTS SHALL CONFORM TO
<br />NATIONAL FIRE PROTECTION ASSOC. 70, NATIONAL ELECTRICAL CODE (N.E.C.) LATEST EDITION AND ALL APPLICABLE LOCAL CODES.
<br />CHEMICAL FEED PUMPS TO BE INTERLOCKED WITH THE RECIRCULATION PUMP.
<br />3. EQUIPMENT - ALL PUMPS, FILTERS AND DISINFECTION EQUIPMENT SHALL BE TESTED AND APPROVED BY THE PERTINENT
<br />MANUFACTURER USING THE NSF/ANS1 STANDARD 50 AND LISTED AS APPROVED BY THE NSF.
<br />4. THE FILTER ROOM FLOOR IS SLIP RESISTANT AND SLOPED TO FLOOR DRAINS
<br />S. ALL PLASTIC PIPING SUBJECT TO PROLONGED SUNLIGHT EXPOSURE MUST BE COATED TO PROTECT IT FROM ULTRAVIOLET
<br />LIGHT DEGRADATION.
<br />6. EACH WASTE LINE SHALL HAVE A UNIQUE AIR GAP. WASTE LINES FROM DIFFERENT SOURCES (E.G. POOL, SPA, OVERFLOW,
<br />SUMP PUMP) SHALL NOT BE TIED TOGETHER BUT MAY DISCHARGE INTO A COMMON SUMP OR RECEPTACLE.
<br />7. THE WASTE LINE MUST BE CONNECTED TO AN APPROVED WASTE DISPOSAL SYSTEM ACCORDING TO LOCAL OR STATE CODES.
<br />B. ALL COLLECTOR TANKS SHALL HAVE COVED INTERSECTIONS AND SLOPE TO THE TANK DRAIN.
<br />9. AN AUTOMATICAND MANUALWATER MAKEUP CONTROL MUST BE PROVIDEDTO MAINTAIN THE WATER LEVELATTHE LIP OFTHE
<br />OVERFLOW GUTTER OR AT THE MOUTH OF THE RECESSED AUTOMATIC SKIMMERS AND MUST DISCHARGE THROUGH AN AIR GAP
<br />INTO A FILL PIPE OR COLLECTOR TANK. OVER THE RIM FILL SPOUTS ARE PROHIBITED.
<br />10. A RATE OF FLOW INDICATOR, READING IN GPM, SHALL BE INSTALLED ON THE FILTER RETURN LINE. THE RATE OF FLOW
<br />INDICATOR SHALL BE PROPERLY SIZED FOR THE DESIGN FLOW RATE AND SHALL BE CAPABLE OF MEASURING FROM ONE HALF TO
<br />AT LEAST ONE -AND -ONE-HALF TIMES THE DESIGN FLOW RATE. THE CLEARANCES UPSTREAM AND DOWNSTREAM FROM THE
<br />RATE OF FLOW INDICATOR SHALL COMPLY WITH THE MANUFACrURER'S INSTALLATION SPECIFICATIONS.
<br />11. THESE PLANS HAVE BEEN PREPARED IN COMPLIANCE WITH THE 2020 FLORIDA BUILDING CODE - SEVENTH EDITION
<br />FILTER EQUIPMENT LIST
<br />RECIRCULATION PUMP
<br />PENTAIR EQKT1DOO, 10 HPWITH BASKETSTRAINER, SELF -PRIMING,
<br />515 GPM @ 60'TDH, 208-23OV, 30, 26AA
<br />VFD (RECIRC)
<br />CES, PFDX 10 HP VARIABLE FREQUENCY DRIVE
<br />DECK JET PUMP
<br />SPECK, 95X, 7.5 HP WITH BASKET STRAINER, SELF -PRIMING,
<br />250 GPM @ 60' TDH, 208-23OV, 30,19.9A
<br />VFD (DECK JET)
<br />CES, PFDX 7.5 HP VARIABLE FREQUENCY DRIVE
<br />FILTER ELEMENTS (DECK JET)
<br />UNICEL, ST155, 1S5 SQ FT EACH, 775 SQ FT TOTAL (290 GPM MAX)
<br />BUBBLER PUMP
<br />PENTAIR MAX-E-PRO XF VS, 5 HIP WITH BASKET STRAINER,
<br />SELF -PRIMING, 150 GPM @ 60- TDH, 208-23OV, 30,13.9A
<br />FILTER TANK
<br />AT1100, 1100 GALLON CAPACITY
<br />SAND FILTER (3)
<br />48" VERTILAL SAND FILTER, 12.15 SQ. FT., 315.45 SQ. FT. rO7AT
<br />547 GPM FILTRATION CAPACITY
<br />WATER LEVEL CONTROL
<br />AQUATEK HYDRAULIC VALVE W/ MANUAL FILL VALVE & RESERVOIR
<br />CHLORINE FEEDER
<br />STENNER 85MS, 85 GPD CAPACITY, 11OV, 13A
<br />CHLORINE RESERVOIR TANK
<br />65 GALLON WITH LOCKABLE LID
<br />pH FEEDER
<br />STENNER 45MS, 50 GPD CAPACITY, 11OV, 13A
<br />pH RESERVOIR TANK
<br />30 GALLON WITH LOCKABLE LID
<br />RECIRC FLOWMETER
<br />6" BLUE/WHITE F-30600P, 170 TO 1100 GPM RANGE
<br />THERMOMETER
<br />PRECISION INSTRUMENT CO B2B1-K WITH 1/2" NPTTHERMOWELL
<br />30* TO 240*F RANGE
<br />VACUUM GAUGE
<br />WIKA, 0-30 IN HG, LIQUID FILLED, 1/4" NPT, 2" FACE DIAMETER
<br />CHEMISTRY CONTROLLER
<br />CES, MR3, CHEMISTRY CONTROLLER WITH SALINE COMPATIBILITY
<br />CHLORO-SALINE GENERATORI
<br />CES, CHLORKING SM15.0, 15 LBS PER DAY 115V
<br />6" RECIRC SUCTION
<br />8" FEATURE DRAIN J
<br />10" GUTTER DRAIN
<br />PIPE AND VALVES CHART
<br />LINE FUNCTION
<br />SIZE
<br />MAIN DRAIN
<br />101.
<br />GUTTER DRAIN
<br />101.
<br />FEATURE DRAIN
<br />8"
<br />STATIC LINE
<br />2"
<br />FRESH WATER FILL
<br />1.1
<br />OVERFLOW
<br />3"
<br />RECIRCULATION PUMP SUCTION
<br />6"
<br />RECIRCULATION RETURN TO FILTERS
<br />6..
<br />RECIRCULATION RETURN
<br />6"
<br />DECK JET PUMP SUCTION
<br />6"
<br />DECK JET RETURN
<br />4"
<br />BUBBLER PUMP SUCTION
<br />4"
<br />BUBBLER RETURN
<br />3"
<br />TO SALINE
<br />V.
<br />FROM SALINE
<br />I.,
<br />BACKWASH LINE (3)
<br />3"
<br />4" DIA. POOL MAINTENANCE LINE
<br />GRAVEL FLOOR
<br />8" MAINTENANCE DRAIN LINE TO STORM
<br />DRAINAGE SYSTEM- VIA AIR GAP (REFER TO
<br />PLUMBING DRAWINGS FOR CONTINUATION
<br />OF PIPE)
<br />4" BUBBLER PUMP SUCTION
<br />10" MAIN DRAIN
<br />1" AUTOFILL
<br />2" LEVEL CONTROL
<br />2" OVERFLOW WITH
<br />CHECK VALVE
<br />d
<br />J
<br />IL
<br />�4
<br />c
<br /><
<br />w
<br />0
<br />u_
<br />_j
<br />Lu
<br />20)
<br />0
<br />2 Lo
<br />0 OD
<br />7
<br />u
<br />-I--
<br />(y)
<br />m
<br />0�1
<br />Z
<br />Ui
<br />co
<br />110
<br />v-
<br />(y)
<br /><
<br />a)
<br />c
<br />,
<br />c:
<br />0
<br />N
<br />q-
<br />11;t
<br />co
<br />I
<br />CN
<br />0
<br />P7_
<br /><
<br />r,4
<br />0
<br />Z
<br />Q
<br />0
<br />I
<br />LL_
<br />=
<br />a)
<br />>
<br />@)
<br />V)
<br />0
<br /><
<br />u-
<br />0
<br />Lu
<br />F__
<br /><
<br />0%,
<br />r—
<br />LLJ
<br /><
<br />Z
<br />W
<br />Lu
<br />I
<br /><
<br />0
<br />0
<br /><
<br /><
<br />0
<br />0
<br />(0
<br />cy)
<br />Lu
<br />j
<br />0
<br />0
<br />W-1
<br />U)
<br />r
<br />uj
<br />0
<br />111
<br />uj
<br />N
<br />Ld
<br />z
<br />LLI
<br />2
<br />ui
<br />J
<br />0
<br />0
<br />IL
<br />REV. DESCRIPTION DATE
<br />PERMIT SET 12-10-2021
<br />DRAWN ICHECKED
<br />zio IRMT
<br />DATE ISCALE
<br />12-17-2021
<br />SHEET OF 121
<br />FILTER TANK
<br />SIDE ELEVATION
<br />FILTER TANK
<br />COMPONENTS ID - PLAN
<br />FILTER TANK
<br />COMPONENTS ID - PLAN
<br />PE-1 I
<br />
|