|
QUAD ELEC. BOX
<br />D-—Ul UTILITY CENTER
<br />3)NOT TO SALE
<br />GENERAL NOTES:
<br />THIS DRAWING IS FOR INFORMATIONAL
<br />PURPOSES ONLY. CONSULT ACTUAL
<br />MANUFACTURER'S TEMPLATE WHEN
<br />INSTALLING EQUIPMENT.
<br />LOCAL REGULATIONS PROVIDE THAT
<br />LICENSED PLUMBERS AND ELECTRICIANS
<br />SHALL INSTALL UTILITIES.
<br />ALL PLUMBING AND ELECTRICAL MUST
<br />MAXIMUM HEIGHT
<br />CONFORM TO PREVAILING LOCAL CODES.
<br />OF OPENED
<br />VALVE- 6"
<br />AIR AND WATER: MANUALSHUT-OFP
<br />VALVES.
<br />VACUUM- 5/8-O.D. TUBE
<br />ELEC. - ALLOW V!
<br />OF 1/2" FLEX
<br />ELECTRICAL° I I 5VAC, 60 HZ, TO BE
<br />CONDUIT TO
<br />INSTALLED WITH GFCI PROTECTED
<br />EXTEND BEYOND
<br />RECEPTACLE OUTLETS, CHECK AMPERAGE
<br />STUB -UP FOR ELEC,
<br />REQUIREMENTS,
<br />HOOK-UPS
<br />CONNECTIONS:
<br />ALL NITROUS OXIDE LINES ARE 3/8!'O.D.
<br />ALL
<br />PIPING,O
<br />02
<br />ALL OXYGEN LINES ARE I /2'O.D, INLET HOSE BARB
<br />COPPER PIPING. USE D.I.S.S. FITTINGS TO INLET TO BAG TEE
<br />CONNECTST I UBS TO FLOWMETER.
<br />NOTE: D,I,S.S. FITTINGS MUST BE
<br />ACCESSIBLE.
<br />THIS IS A TYPICAL UNIT.
<br />REFER TO MANUFACTURER'S
<br />INSTALLATION LITERATURE TO VERIFY TOP VIEW
<br />REQUIREMENTS.
<br />CLEARANCE V-0 3/16"
<br />FORHHOSE
<br />41/2 115/9,
<br />3
<br />t
<br />CD
<br />+ z E'
<br />NITROUS OXYGEN m.
<br />L-- — —
<br />LEFT SIDE VIEW FRONT VIEW
<br />NITROUS OXIDE FLOWMETER
<br />NOT TO SCALE
<br />GENERAL NOTES:,
<br />THIS DRAWING IS FOR INFORMATIONAL PURPOSES ONLY. CONSULT ACTUAL MANUFACTURER'S TEMPLATE
<br />WHEN INSTALLING EQUIPMENT.
<br />LOCAL REGULATIONS PROVIDE THAT LICENSED PLUMBERS AND ELECTRICIANS SHALL INSTALL UTILITIES.
<br />ALL PLUMBING AND ELECTRICAL MUST CONFORM TO PREVAILING LOCAL CODES.
<br />WATER* 35-40 PSI AIR: 70-80 PSI
<br />1/2" O.D. (1.27cm) COPPER TUBING WITH I /Z'NPT MALE FITTING. STUB -Up 1-112'(3.81cm) FIRQ MANISHED,
<br />FLOOR SURFACE. FLUSH ALL DEBRIS FROM LINE BEFORE INSTALLING VALVES,
<br />NOTE: AIR AND WATER SHUT-OFF VALVES CAN NOT EXTEND MORE THAN 6" ABOVE FINISHED FLOOR
<br />SURFACE, FULLY OPENED.
<br />VACUUM.
<br />WATER —AIR N20 02 5/6'O,D. (I .59trri) COPPER TUBING, TYPE L (.045 WALL THICKNESS), STUMP IlT (1.27cm) MIN., I" (2,54cm)
<br />FINISHED FLOOR SURFACE
<br />MAX FROM FINISHED FLOOR OR WALL SURFACE. ELBOW CONNECTION FURNISHED BY P&C TO BE
<br />SOLDERED IN PLACE.
<br />-----VACUUM'
<br />ELECTRICAL:
<br />STUB -UP WITH 1 /7'(1.27cm) FLEXIBLE CONDUIT FOR CONNECTION TO THE POWER STRIP. CIRCUIT SHOULD
<br />BE 120 VAC. DEDICATED 15 AMP.
<br />NODE: ELECTRICAL INSTALLATION MOST MEET ALL APPROPRIATE ELECTRICAL CODES, CONSULT ELECTRICAL
<br />CONTRACTOR TO PROVIDE A Ill 5 VAC RECEPTACLE.
<br />ISAL RI CABINET UTILITIES
<br />NOT TO SC
<br />ELECTRICAL CONTRACTOR IS USE 12 AWG WIRE BETWEEN CONTROL BOX AND
<br />RESPONSIBLE FOR FOLLOWING ALL X-RAY UNIT FOR TOTAL WIRE LENGTH UP TO 50 FEET.
<br />LOCAL CODES FOR ROUGH
<br />INSTALLATION. HENRY SCHEIN TO 10 AWG WIRE IS REQUIRED WHEN WIRE LENGTH IS
<br />Q-
<br />MAKE FINAL CONNECTIONS. BETWEEN 50-75 FEET,
<br />ELECTRICIAN TO PROVIDE A
<br />FLUSH -MOUNTED SINGLE GANG
<br />JUNCTION BOX & 3/4!'CONDUIT W/
<br />PULL -WIRE FROM CONTROL BOX
<br />TO X-RAY UNIT.
<br />POWER FROM BUILDING MOUNTING PLATE. CONTROL
<br />ELECTRICAL PANEL. 120V, BOX CAN BE MOUNTED
<br />DEDICTATED 15A CIRCUIT ADJACENT TO X-RAY UNIT OR IN
<br />HALL. SEE .SHEET SE.1 FOR
<br />LOCATION, SEE HENRY SCHEIN
<br />PANEL CUTOUT
<br />NOTE OWER REP FOR EXACT HEIGHT.
<br />LOW -VOLTAGE & WER
<br />CABINET (SEE CABINET DRAWINGS
<br />FOR ACTUAL CABINET LAYOUT)
<br />AUTOCLAVE OUTLET SEPARATE CIRCUIT 20 AMP
<br />HEIGHTS TO BE DETERMINED
<br />0-
<br />AUTOCLAVE PROVIDED AND
<br />INSTALLED BY HENRY SCHEIN DENTAL
<br />STATIM, OUTLET SEPARATE 15 AMP CIRCUIT
<br />HENRY SCHEIN DENTAL EQUIPMENT SPECIALIST
<br />TO DETERMINE LOCATION.
<br />NOTE* SWITCHED OUTLET RECOMMENDED.
<br />--�STATIM PROVIDED AND INSTALLED
<br />1 'no
<br />BY HENRY SCHEIN DENTAL
<br />CONDENSER BOTTLE
<br />OUTLETS PROVIDED AND
<br />INSTALLED BY CONTRACTOR
<br />AUTOCLAVE AND STATIM OUTLET.
<br />NOT TO SCALE
<br />MODEL
<br />1025D
<br />5
<br />TOTAL HP
<br />1.5
<br />VOLTAGE
<br />230
<br />BREAKER$Zi
<br />20A
<br />HERTZ
<br />610
<br />AMPS
<br />8.4
<br />TANKSIZE
<br />10 GAL.
<br />WIDTH
<br />24-3U'
<br />DEPTH
<br />20,$-271,
<br />1 HEIGHT
<br />2615 30"
<br />IWEIGHT
<br />174LBS
<br />NOTES.
<br />1. SUPPLY HOSE, 1/4'mtpx3/6'mtp, &LONG (SUPPLIED)
<br />2. DRAIN TUBING, 3/9'PLASTIC, 4' LONG (SUPPLIED)
<br />3. BUSHING, I]Tmpt x 3/Vlfpt (SUPPLIED)
<br />4. ALLOW 6" S . ERVICE CLEARANCE ON SIDES., BACK AND TOP OF COMPRESSOR.
<br />MAINTAIN I Z'CLEARANCE IN FRONT OF COMPRESSOR.
<br />CONNECT FRESH AIR INTAKE (USES V HOSE BARB) TO
<br />EXTERNAL AIR SOURCE PER NFPA 99C
<br />RECOMMENDATIONS.
<br />CONNECT UNIT TO OUTLET ON 230V, 20A DEDICATED
<br />CIRCUIT.
<br />LOW -VOLTAGE CONTROL WIRING TERMINALS. MAX.
<br />DISTANCE FOR 18 GA. WIRE-- 500 FT,
<br />CONNECT UNIT TO FACILITY PLUMBING USING PROVIDED
<br />SUPPLY HOSE. USE BUSHING IF NECESSARY.
<br />NOTE:
<br />INSTALL UNIT PER. FOLLOWING ALL LOCAL & STATE CODES.
<br />RMC1025D IRCAOMPRESSOR
<br />j NOT TO SCALE
<br />MAY REQUIRE SEPARATE
<br />JUNCTION BOXES. VERIFY LOCAL
<br />CODE REQUIREMENTS.
<br />di
<br />uj
<br />LOW -VOLTAGE WIRE TO X-RAY
<br />>
<br />UNIT (SPEC. 9)
<br />SEE MANUFACTURER'S INSTALLATION MANUAL FOR MORE DETAIL,
<br />BEL 096 X—RAY CONTROL BOX
<br />NOT TO SCALE
<br />DOUBLE BOWL SINK
<br />(MAY VARY TO SINGLE BOWL)
<br />RECESSED ULTRASONIC CLEANER
<br />REMOTE TIMER PANEL
<br />ULTRASONIC CLEANER
<br />DRAIN
<br />ULTRASONIC CLEANER GENERATOR
<br />ADJUSTABLE SHELF
<br />1
<br />ULTRASONIC CLEANER.
<br />NOT TO SCALE
<br />ODEL
<br />QT- 1,2
<br />VERIFY AMBIENT ROOM
<br />DISCONNECT
<br />)TAL HP
<br />1.0
<br />---9-5/-230
<br />TEMPERATURE AND
<br />D.LTAGE
<br />VENTILATION REQUIREMENTS
<br />DEDICATED
<br />'EAKER SZ,
<br />20A
<br />WITH MANUFACTURE
<br />CIRCUIT
<br />RTZ
<br />mps
<br />13.4/6,7
<br />PRE -INSTALLATION GUIDE
<br />7
<br />BUILDING
<br />IDTH
<br />25'
<br />POWER
<br />=PTH
<br />SUPPLY
<br />PANEL
<br />TO OPTIONAL REMOTE
<br />CONT ZOL PANEL Q
<br />EXHAUST TO
<br />ELECTROL
<br />OUTSIDE BUILDING
<br />(SUPPLIED BY RAMVAC)
<br />(Z'SCH. 80 PVC
<br />OR METAL)
<br />JUNCTION BOX
<br />(OPTIONAL)
<br />0
<br />15 GAL. OTTER
<br />TANK
<br />TREATMENT ROOM
<br />DRAIN LINE (TO
<br />SEE DETAIL(S) 1,3 OR 3A FOR VACUUM
<br />FLOOR DRAIN
<br />LINE STUB -UP REQUIREMENTS WITHIN
<br />.
<br />OR P-TRAP) -I 1 /2'
<br />ROOM.
<br />PV PI
<br />C
<br />FLOOR PE
<br />--------- - - TR TANK LINE- 1 1/2'OR 2" PVC W/ DWV
<br />VACUUM LINES PER LOCAL CODE, FITTINGS OR COPPER PER LOCAL CODE
<br />SLOPE MINIMUM I/4PPER 10 FEET. WOTEW'
<br />REFER TO RAMVAC SPECS AND PRE -INSTALLATION GUIDE FOR
<br />EXACT REQUIREMENTS. VERIFY LOCAL CODES BEFORE INSTALLING
<br />UNIT,
<br />\BULLDOG COMBO 1 &2
<br />NOT TO SCALE
<br />ELECTRICAL CONTRACTOR IS
<br />RESPONSIBLE FOR FOLLOWING ALL
<br />LOCAL CODES FOR ROUGH
<br />INSTALLATION. HENRY SCHEIN TO
<br />MAKE FINAL CONNECTIONS.
<br />ELECTRICIAN TO PROVIDE A
<br />FLUSH -MOUNTED SINGLE GANG
<br />JUNCTION BOX & 3/4!'CONDUIT W/
<br />PULL -WIRE BETWEEN EXPOSURE
<br />BUTTON & X-RAY MASTER
<br />CONTROL/UNIT.—����
<br />X -RAY EXPOSURE BUTTON f".)—
<br />VERIFY WIRING REQUIREMENTS
<br />BETWEEN EXPOSURE BUTTON
<br />AND X-RAY MASTER
<br />CONTROL/UNIT WITH
<br />MANUFACTURER'S INSTALLATION
<br />MANUAL.
<br />PROVIDED BY HENRY-SCHEIN DENTAL, INSTALLED BY ELECTRICIAN.
<br />SEE MANUFACTURER'S INSTALLATION MANUAL FOR MORE DETAIL.
<br />X—RAY EXPOSURE BUTTON
<br />NOT TO SCALE
<br />COLD WATER,
<br />PLUMBER.'SHALL
<br />PROVIDE AND
<br />INSTALL A CHROME
<br />PLATED ANGLE
<br />STOP (VALVE) TO BE
<br />LOCATED AT
<br />MODEL TRIMMER
<br />MODEL TRIMMER -
<br />115V. 15AMP. ELEC.
<br />OUTLET FOR MODEL
<br />TRIMMER.,
<br />DRAIN HOSE FROM
<br />MODEL TRIMMER TO
<br />EXPEL INTO SINK.
<br />DRAIN HOSE
<br />---
<br />me
<br />FRONT VIEW
<br />MODEL TRIMM
<br />NOTTO.SCALE
<br />314- UNION (2 P'
<br />PROVIDED BY PI
<br />I I 5V WALL OUT
<br />WITHIN 5'OF Wi
<br />FILTER BYPASS,
<br />LOW VOLTAGE
<br />CONTROL WIRE
<br />STANDARD LAB SINK
<br />SUPPLIED AND INSTALLED
<br />BY PLUMBER
<br />FLEX.HOSE (SUPPLIED)
<br />0 SINK DRAIN
<br />0 PLASTER TRAP & HOSES
<br />PROVIDED BY HENRY
<br />SCHEIN DENTAL AND
<br />INSTALLED BY PLUMBER.
<br />BASE OF SINK CABINET
<br />SIDEVIEW
<br />DISP. PLASTER TRAP
<br />NOTE:
<br />WHEN MOUNTING FROM ABOVE OUTLET STATION.
<br />VACUUM PIPING FOR GAS SCAVENGING MUST
<br />INCLUDE VERTICAL LOOP TO PREVENT BACKFLOW
<br />OF LIQUIDS INTO VACUUM BLOCK.
<br />1/2" 01). VACUUM
<br />LINE
<br />1/7'O.D. OXYGEN
<br />FROM TANK ROOM
<br />3/8" O.D. NITROUS
<br />FROM TANK Room
<br />WALL FRAMING------_.,
<br />BRACKET "A" TO
<br />MOUNT TO STUD
<br />BEFORE GYP. BIRD - ---------
<br />PROVIDED BY HENRY SCHEIN
<br />DENTAL AND INSTALLED BY
<br />PLUMBER
<br />THIS DRAWING REPRESENTS A TYPICAL INSTALLATION AND IS FOR INFORMATIONAL PURPOSES ONLY.
<br />REVIEW MANUFACTURER SPECIFICATIONS FOR EXACT MODEL AND SYSTEM REQUIREMENTS.
<br />N20,02AND VACUUM OUTLET STATION
<br />NOT TO SCALE
<br />SEE ACTUAL VALVE TO
<br />ADJUST THE MOUNTING
<br />POSITION OF THE 1, 2„ FPT
<br />ADAPTOR SO THE. TRIM RING IS
<br />SECURED FIRMLY AGAINST THE
<br />S.HEETROCK.
<br />AIR VALVE PROVIDED AND
<br />INSTALLED BY CONTRACTOR,
<br />3/9'COMPRESSION FITTING
<br />OR OPTIONAL FEMALE QUICK
<br />DISCONNECT PROVIDED &
<br />INSTALLED BY CONTRACTOR.
<br />AIR VALVE
<br />NOT TO SCALE
<br />I ITSUP x I /Z'FPT ADAPTOR.
<br />PROVIDED & INSTALLED BY
<br />CONTRACTOR,
<br />1/2" FEMALE ADAPTOR
<br />PROVIDED & INSTALLED BY
<br />QNTRACTOR.
<br />AIR LINE BY CONTRACTC
<br />Q- ®R
<br />ANCHOR TERMINATION
<br />FITTINGS SECURELY TO A
<br />OR A CROSS BRACE.
<br />FITTINGS PROVIDED AND
<br />INSTALLED BY CONTRAC
<br />VACUUM WALL OUTLET
<br />NOT TO SCALE
<br />LOW VOLTAGE CONTROL WIRES -
<br />RUN 18/3 BELL WIRE FROM UNITS TO
<br />MASTER CONTROL PANEL
<br />(CONTRACTOR TO SUPPLY WIRE)
<br />STUB PIPE OUT OF STANDARD SINGLE GANG BOX (2-1/8" D x
<br />WALL 6" 4!'H x 7'W) SUPPLIED BY ELECTRICIAN
<br />MASTER WATER SHUT—OFF W/FILTER
<br />NOT TO SCALE
<br />1 /7'PVC SLIP X SLIP, 900
<br />ELBOW. PROVIDED �&
<br />INSTALLED: BY CONTRACTOR.
<br />ANCHOR TERMINATION
<br />FITTINGS SECURELY TO A STUD
<br />OR A CROSS BRACE,
<br />FITTINGS PROVIDED AND
<br />INSTALLED BY CONTRACTOR.
<br />I /Z'SC-H 40 PVC BRANCH
<br />FROM MAIN TRUNK LINE.
<br />PROVIDED & INSTALLED BY
<br />CONTRACTOR.
<br />60"
<br />THIS IS A TYPICAL INSTALLATION. SEE A.F.F.
<br />MAN U FACTURER'S SPECS FOR EXACT
<br />EQUIPMENT REQUIREMENTS.
<br />, n RA M�V �ACCONTROL PANEL
<br />NOT TO SCALE
<br />ISSUE
<br />DATE
<br />REAM
<br />02/22AI
<br />PERMIT
<br />02/23/11
<br />REV.
<br />REV.
<br />REV.
<br />IREV.
<br />7tME POUMM VM05 NOTE5 MTAiL5 NO
<br />935CMAWM AND CONCEPTS ARE IM SOLE
<br />MMM OF MAZE MM M AND SHALL NOT BE
<br />N"==, M-USED OR GOP® FOR Mat
<br />PROJMI% IN MOLE OR FM MW 7W W7N
<br />CONSENT Of MW FRAM ARGHr=T, AIA6
<br />ALL ROM AM IMURVW BY THE ARCHITECT IN
<br />ACCORDANCE NTH UA COMIOW AND FATEW LAWS.
<br />WAmimm REPRO zTm YcL BE Mwwfxw To
<br />THE FULL EXTENT OF THE LW
<br />O
<br />V)
<br />w
<br />W
<br />/-�
<br />;4
<br />0
<br />4-4
<br />con
<br />4-a
<br />U
<br />1.4
<br />0
<br />u
<br />OfM-9910NAL 5C6L
<br />1,.EO
<br />Glta s ..C)
<br />0 ®°
<br />0
<br />00
<br />uj
<br />ZP
<br />gap I A
<br />SHEET TITLE
<br />M.UMIDING
<br />DETAILS
<br />
|